Indoor Fireplace User Manual

21Heatilator • ECO-WINS18 • 7065-132B • August 29 2011
5
Service Parts Replacement
A. Glass Replacement
(Replace with 5mm ceramic glass only)
1. Ensurethatthereisoutandtheapplianceiscoolto
thetouch.
2. Protectatableorcountertopwithpaddingortowels.
Protectyourhandsandwearglovestopreventinjury.
3. Removethe door with the broken glass bylifting the
doorupandoffofthehinges.
4. Laydoorfacedownonatableorcountermakingsure
thehandlehangsovertheedgesothedoorlaysat,on
asoftsurface.
5. Removethescrewsfromeachglassretainerandremove
theglass.(Ifscrewsaredifculttoremove,soakwith
penetratingoilrst).
6. Center the glass with edges evenly overlapping the
openinginthedoor,(i.e.samespacetopandbottom,
leftandrightsides).
7. Replace the glassretainers.  Be careful notto cross
threadthescrews.
8. Tighten each retainer just a few turns until each is
secured. Check again for centering of glass in door
frame.Continuetotighteneachretaineralternately,a
fewturnsatatime,untiltheglassissecure.DONOT
OVERTIGHTEN-cancauseglasstobreak.
9. Replacethedoorontheappliance.
Heatilatorappliancesareequippedwithceramicsuperheat-
resistantglass,whichcanonlybebrokenbyimpactormisuse.
WARNING! Risk of Fire or Injury!
Useonlyglassthatisspeciedinthemanual,DONOT
replacewithanyothermaterial.Glassbreakagewilloccur.
CAUTION!
Handleglasswithcare.
• Inspectthegaskettoensureitisundamaged.
• DoNOTstrike,slamorscratchglass.
• DoNOToperateappliancewithglass&doorassembly
removed.
• DoNOToperatewithglasscracked,brokenor
scratched.
B. Snap Disc Replacement (Cont;d)
Figure 21.1 Snap Disc Location
1. Removesurroundfromunit.
2. Using a phillips head screwdriver, remove 8-32 screw,
washerandbushingassembliesholdingleftsidepanelin
place.Removepanel.Figure 21.1
UNPLUG APPLIANCE FROM ANY POWER SOURCE
BEFORE REPLACING ANY COMPONENTS
White
Black
White
Black
Black
White
Blower
Snap Disc
Rheostat
Switch
Power Cord
B. Snap Disc Replacement
3.Slidesnapdiscoutofbracketandunplugfromwirehar-
ness.
4. Reinstallinreverseorder.
C. Wiring Diagram
Figure 21.2
SNAP DISC
LEFT SIDE
PANEL
ATTACHMENT
HARDWARE