User Guide

38
Front
Lower Back
Molded Brick Panel
Hearth Molded Brick Panel
Upper Back
Molded Brick Panel
Upper Side
Molded Brick Panel
Lower Side
Molded Brick Panel
Right Side
Molded Brick Panel
removed for
clarity
11
Installation of Molded Brick Panel
A. Install Hearth Molded Brick Panel
• Placehearthpanelintothereplace.
C. Install Back Molded Brick Panel/Traditional
• RefertoFigure11.1.
• Setthegratebracketsinplace,26.5in.(673mm)center
to center.
• Installthelowerbackpanel.Centerfromsidetoside.
• InstallthreeT-bracketsstemdownintomortarlinetohold
lowerbackinposition.Donottighten.
• Installupperbackpanel.Positionbottomofpanelbehind
thepreviouslyinstalledT-brackets.
• InstalltwoT-bracketsstemsideupintomortarline,donot
tighten
• InstalltwoZ-bracketsinthemortarlinesacrossthetop.
Tightentheseandallpreviouslyinstalledbrackets.
B. Install Side Molded Brick Panel/Traditional
• Ifagaslineistobeinstalled,removetheknockoutsin
the inner rebox and in the outer shell on the side of
yourchoice.Refertodimensiondrawingsforlocationof
knockoutsandSection13.A.forgasprovisions.
• DoNOTremovescreenrods.
• RefertoFigure11.1.
• Installlowersidepanel,taperededgetothefront.Align
thefrontedgewiththefrontofthecolumn(orbuttedto
thesurroundifinstalled).
• InstalltwoT-bracketsstemdownintomortarline,donot
tighten.
• Install upper side panel in the unit, tapered edge to
the front. Position the bottom of panel behind the T-
brackets.
• InstalltwoT-bracketsstemupintomortarlines,oneon
itssideonthefrontedge,donottighten.
• InstalltwoZ-bracketsinthemortarlinesacrossthetop.
Tightentheseandallpreviouslyinstalledbrackets.
• Installsecondsidepanelfollowingthestepsabove.
Note: Use T-brackets as templates and drill pilot
holesintotheinnershellwiththedrillbitprovided.
Sidepanelsmustbeinstalledrst.
Figure 11.1 Traditional Molded Brick Panel
Heatilator•BirminghamBIR42•4059-308RevJ•1/11