User Guide

ManualsBrandsHatco ManualsOtherTR-TKM-0400

TOAST-RITE

& TOAST KING

Electric Conveyor Toasters

TRH & TK Series

Installation &

Operating Manual

I&W #07.05.002.00

This manual contains important safety information

concerning the maintenance, use and operation of

this product. Failure to follow the instructions con-

tained in this manual may result in serious injury.

If you’re unable to understand the contents of this

manual, please bring it to the attention of your super-

visor. Do not operate this equipment unless you have

read and understood the contents of this manual.

Este manual contiene importante información sobre

seguridad concerniente al mantenimiento, uso y

operación de este producto. Cualquier falla en el

seguimiento de las instrucciones contenidas en este

manual puede resultar en un serio daño. Si usted no

puede entender el contenido de este manual por

favor pregunte a su supervisor. No opere este equipo

al menos que haya leído y comprendido el contenido

de este manual.

Summary of content (16 pages)

PAGE 1
TOAST-RITE & TOAST KING ® ® Electric Conveyor Toasters TRH & TK Series Installation & Operating Manual I&W #07.05.002.00 This manual contains important safety information concerning the maintenance, use and operation of this product. Failure to follow the instructions contained in this manual may result in serious injury. If you’re unable to understand the contents of this manual, please bring it to the attention of your supervisor.
PAGE 2
CONTENTS Important Owner Information..................................i Introduction.................................................................i Important Safety Instructions ..................................1 Model Descriptions ....................................................2 All Models............................................................2 Toast-Rite (TRH) Models ....................................2 Toast King (TK) Models ......................................2 Specifications...........
PAGE 3
IMPORTANT SAFETY INSTRUCTIONS Read the following important safety instructions to avoid personal injury and/or damage to the equipment. around the motor compartment. Do not place toaster in direct discharge path of air conditioning vent or makeup air vent. ! WARNINGS ! 1. To avoid any injury, turn the power switch off, unplug the unit from the power source and allow to cool before performing any maintenance. ! 2.
PAGE 4
MODEL DESCRIPTION ALL MODELS All Toast-Rite and Toast King Electric Conveyor Toasters are fast, dependable and versatile, toasting up to 500 or 1550 slices of bread product per hour. Every unit includes a toast collector pan, heated toast storage area, power saving thermostat, speed control, manual advance, and factory attached 4' (122 cm) cord and plug. TOAST-RITE MODELS ER TRH-60 The TRH-60 model toasts up to 10 bread or bun slices per minute (600 per hour) and features toasting baskets two-slices wide.
PAGE 5
SPECIFICATIONS ELECTRICAL RATING CHART – TOAST- RITE SERIES Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight TRH-50 120 60 2738 22.8 NEMA 5-30P 64 lbs. (29 kg) 208 60 2738 13.2 NEMA 6-20P 64 lbs. (29 kg) 240 60 2738 11.4 NEMA 6-20P 64 lbs. (29 kg) 220 60 2738 12.5 CEE 7/7 Schuko 64 lbs. (29 kg) 220 50 2738 12.5 CEE 7/7 Schuko 64 lbs. (29 kg) 220/380 3Ø 50 2700 4.6 None 64 lbs. (29 kg) 220-230 CE 50 2738-2993 12.5-13.0 CEE 7/7 Schuko 64 lbs.
PAGE 6
SPECIFICATIONS ELECTRICAL RATING CHART – TOAST KING SERIES Model Voltage Hertz Watts Amps Plug Configuration Shipping Weight TK-72 208 60 4038 19.4 NEMA 6-20P* 76 lbs. (35 kg) 240 60 4038 16.8 NEMA 6-20P* 76 lbs. (35 kg) 200 50 3733 18.7 NEMA 6-20P 76 lbs. (35 kg) 220-230 CE 50 4038-4414 18.4-19.2 No Cap 76 lbs. (35 kg) 220 50 4038 18.4 No Cap 76 lbs. (35 kg) 220 60 4038 18.4 No Cap 76 lbs. (35 kg) 230-240 CE 50 3708-4038 16.1-16.8 No Cap 76 lbs.
PAGE 7
SPECIFICATIONS PLUG CONFIGURATIONS Units are supplied from the factory with an electrical cord and plug installed on the back of the unit. See ELECTRICAL RATING CHART and Figure 3. The circuit must be sized depending on the model amp rating. NOTE: See the specification plate located on the front of the unit at the control panel for proper electrical requirements.
PAGE 8
SPECIFICATIONS DIMENSIONS – TOAST-RITE MODELS Model Width (A) Depth (B) Depth (C) Height (D) TRH-50 17-1/2" (45 cm) 22-1/2" (57 cm) 27-1/2" (70 cm) 16-1/4" (41cm) TRH-60 17-1/2" (45 cm) 22-1/2" (57 cm) 27-1/2" (70 cm) 16-1/4" (41 cm) TRH-100B 17-1/2" (45 cm) 22-1/2" (57 cm) 27-1/2" (70 cm) 16-1/4" (41 cm) A B D C Front View Side View Figure 4.
PAGE 9
INSTALLATION GENERAL 1. Remove unit from box. 2. Remove information packet. To prevent delay in obtaining warranty coverage, fill out and mail in warranty card. 3. Remove tape and packaging materials. U RK ER E L IG H T R L DA NOTE: Remove the tube of lubricating oil taped to the toast collector pan. Retain for future lubrication of the gear motor. 4. Install toast collector pan to unit. See Figure 6.
PAGE 10
OPERATION ALL MODELS UL 1. Plug cabinet into an electrical outlet of the correct voltage, size and plug configuration. See Specifications for details. Speed Control RK ER L IG H TE R DA 2. Turn the Selector Switch, located on the front panel, to “Toast” or “Buns”. See Figure 7. Thermostat Adjustment Screw NOTE: When toasting buns, place cut side down and set Selector Switch to the “Buns” position. When toasting bagels, place cut side up and set Selector Switch to the “Toast” position. 3.
PAGE 11
MAINTENANCE GENERAL Hatco Electric Conveyor Toasters are designed for maximum durability and performance, with minimum maintenance. ! WARNING To avoid any injury, turn the power switch off, unplug the unit from the power source and allow to cool before performing any maintenance. CLEANING Exterior To preserve the bright finish of the unit, it is recommended that the exterior surfaces be wiped daily with a damp cloth.
PAGE 12
MAINTENANCE Motor Bearing Lubrication Schedule 3. Lubricate the bearing by applying 10-12 drops of Mobil SHC 624 lubricant (Hatco part no. 05.01.018.00) to the bearing. See Figure 9. 24 hours operation . . . . . . . . . . . . . . . .Every 6 weeks 18 hour operation . . . . . . . . . . . . . . . . .Every 8 weeks 12 hour operation . . . . . . . . . . . . . . . .Every 12 weeks Periodic operation . . . . . . . . . . . . . . . .Every 6 months 4. Re-install the rear access panel.
PAGE 13
LIMITED WARRANTY THE FOREGOING WARRANTIES ARE EXCLUSIVE AND IN LIEU OF ANY OTHER WARRANTY, EXPRESSED OR IMPLIED, INCLUDING BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR PATENT OR OTHER INTELLECTUAL PROPERTY RIGHT INFRINGEMENT.
PAGE 14
NOTES Form No.
PAGE 15
NOTES 13 Form No.
PAGE 16
HATCO AUTHORIZED PARTS DISTRIBUTORS ALABAMA Jones McLeod Appl. Svc. Birmingham 205-251-0159 LOUISIANA (Continued) Bana Comm. Parts, Inc. Shreveport 318-631-6550 OHIO (Continued) E. A. Wichman Co. Toledo ARIZONA Auth. Comm. Food Equip. Phoenix 602-234-2443 MARYLAND Electric Motor Service Baltimore 410-467-8080 OKLAHOMA Hagar Rest. Service, Inc. Oklahoma City 405-235-2184 Byassee Equipment Co. Phoenix 602-252-0402 CALIFORNIA Industrial Electric Huntington Beach 714-379-7100 GCS Service, Inc.