Operation Manual

Warning:
Warning against dangerous electric
voltage
Warningn against automatic
running-on
Orders:
Read the Operation Manual
Environment Protection:
Do not place waste in the
surrounding environment, have it
disposed by professionals.
Cardboard packing material can
be delivered to recycling
establishments reserved for
disposal thereof
Faulty electric or electronic devices and/ or those determined for
disposal shall be delivered to recycling establishments authorized for
disposal thereof.
Packing:
Protect against moisture
Packing orientation:
up/on the top
Use in accordance with the Conditions
The home water station is designated exclusively for pumping
clean water for the purpose or water supply in the house, in
the garden, in the courtyard and in agriculture. Should the
provisions of generally applicable regulations and provisions
in this Manual be not observed, the manufacturer cannot be
responsible for damages.
Remaining Dangers and Protection Measures
Electric Remaining Dangers
Danger Description Protection Measures
Direct
electric
contact
Electric shock Insufficient current switch FI
Indirect
electric
contact
Electric shock
via the medium
Insufficient current switch FI
Disposal
The instruction for disposal are to be found in pictograms
located on the device and/or on the packing. The explanation
of individual terms can be found in Chapter “Marking on the
Device”.
The Requirements on the Operator
The Operator shall carefully read the Operation Manual
before using the device.
Qualification
The professionaly versed person does not need any special
qualification for using the device.
Minimum Age
The devfice may only be operated by persons at the age of 16
and more.
The exception is using the device by an adolescent in the
course of his training for the profession, where the device is
used for the purpose of getting the skill under supervision of
the instructor.
Training
The operator who is going to operate the device will only need
to get corresponding training by a professionally versed,
and/or a training according to the Operation Manual. No
special training is necessary.
Technical data
HWW 1000 IE
Supply main 230 V/50 Hz
Engine P1 output 1000 W/P1
Max. suction height 8 m
Max. pumped quantity 3500 l/h
Max. pumping height 44 m
Supply main 1‘‘ IG
Way of protection IP X4
Water temperature 35 °C
L
WA
86 dB
Weight approx. 15,5 kg
Assortment position No. 94668
Transport and Storing
When storing in winter, make sure that no water is in the
device, otherwise the device may be destroyed due to
freezing.
For any transport, the pump is remove the power cord!
The pump must be completely emptied and frost-proof
storage. Sticking to the mechanical seals is reduced in the
pump with a suitable oil (eg vegetable oil) is washed.
Assembly and First Putting into
Operation
Pre-filter and strainer
Sandy earth and water must be operated at the pump with a
filter (available separately) between the hose and pump
casing (Fig. E). Always use only with the inlet check valve and
strainer. The ingress of sand into the mechanical seal
(connecting shaft motor - pump) would destroy them! Even
within the warranty period, this would be a blame themselves
and thus excluded from any warranty.
Safety Instructions for First Putting into Operation
Caution: The pump shall never be operated without water.
The pump is not used for conveying drinking water!
When using the pump (water equipment) the user is
responsible to third persons
The user may operate the pump only on connecting lines
furnished with the insufficient current switch (FI switch)!
Before putting into operation the authorized electrician should
check if there are required electric safety measures available.
The electric connection shall be performed by means of a
socket.
Voltage examination. Technical data on the label shall comply
with the electric network voltage.
11