Product Name: Cyclone Harness Series Part #: 21064; 21065; 21066; 21067; 21033; 21034; 21035; 21036; 21029; 21030; 21031; 21032; 21052; 21053; 21054; 21055; 21045; 21046; 21047; 21048; 21041; 21042; 21043; 21044; 21082; 21083; 21056; 21057; 21058; 21059; 21060; 21061; 21062; 21063 Instruction Manual Do not throw away these instructions! Read and understand these instructions before using equipment! Introduction 1 Applicable Safety Standards 1 Worker Classifications 1 Product Specific Applications 2
User Information Date of First Use: Serial #: Trainer: User: Applicable Safety Standards When used according to instruction specifications, this product meets or exceeds all applicable OSHA 1926 Subpart M, OSHA 1910, ANSI Z359.11-2014, and ANSI A10.32-2012 standards for fall protection. Applicable standards and regulations depend on the type of work being done, and also might include state regulations if applicable.
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 ! WARNING Use of equipment in unintended applications may result in serious injury or death. Maximum 1 attachment per connection point. Personal Fall Arrest: Cyclone Harness may be used to support a MAXIMUM 1 PFAS for use in Fall Arrest applications. Structure must withstand loads applied in the directions permitted by the system of at least 5,000 lbs.
Anchor Point Level w/Dorsal D-ring 6’ Free Fall 12’ Free Fall Lanyard Lanyard Anchor Point at Foot Level Swing Falls: Prior to installation or use, make considerations for eliminating or minimizing all swing fall hazards. Swing falls occur when the anchor is not directly above the location where a fall occurs. Always work as close to in line with the anchor point as possible. Swing falls significantly increase the likelihood of serious injury or death in the event of a fall.
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 Components and Specifications Materials: polyester, nylon, steel, and aluminum.
www.guardianfall.com ! WARNING 4. Adjust chest strap height to lower chest level, approximately 6” from top of shoulders. Connect chest strap. Ensure there is no twisting of webbing. 5. Adjust chest, leg, and shoulder straps so they fit snugly, but still allow for a full range of movement. Any twisting of webbing, or straps that are fitted too loose or too tight, can significantly increase the risk of serious injury or death in the event of a fall.
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 Prior to EACH use, inspect Cyclone Harness for deficiencies, including, but not limited to, corrosion, deformation, pits, burrs, rough surfaces, sharp edges, cracking, rust, paint buildup, excessive heating, alteration, broken stitching, fraying, and missing or illegible labels. IMMEDIATELY remove Cyclone Harness from service if defects or damage are found, or if exposed to forces of fall arrest.
Do not alter equipment. Do not misuse equipment. Workplace conditions, including, but not limited to, flame, corrosive chemicals, electrical shock, sharp objects, machinery, abrasive substances, weather conditions, and uneven surfaces, must be assessed by a Competent Person before fall protection equipment is selected.
ANSI Z359.11–2014 90781 (Rev. D)-1 ANSI Z359 recognizes the use of this harness only within the capacity range of: 130–310 lbs. www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 Labels Compliant with: OSHA 1910, OSHA 1926 Subpart M, ANSI Z359.11-2014, and ANSI A10.32-2012. Size: S S-M L M S-L M-L M-XL L-XL XXL XL-XXL XL Material: Polyester & steel Part #: Capacity Range: 130-420 lbs. Make only compatible connections.
1. It is essential that the users of this type of equipment receive proper training and instruction, including detailed procedures for the safe use of such equipment in their work application. ANSI/ASSE Z359.
www.guardianfall.com phone: (800) 466-6385 fax: (800) 670-7892 6305 S. 231st St., Kent, WA 98032 USA Guardian Fall Protection If the sternal attachment is used for fall arrest, the competent person evaluating the application should take measures to ensure that a fall can only occur feet first. This may include limiting the allowable free fall distance.
