User Guide

Technical Specifications
We are professional access system specialists
DC SERIES
Visit us on the web: www.gtopro.com
SW
GTO® and GTO/PRO® are registered trademarks of GTO, Inc. © 2005, Rev. 3/16/05
PRO-SW3000
DRIVE
• Powered by a reliable 12 Volt DC motor,
64:1 planetary gear drive system.
• Temperature rating of motor: -5° F
(-28° C ) to +160° F ( 71° C).
• Opening time is 20-24 seconds.
• Range of arm stroke is up to 16”
(41 cm). Operator length with arm fully
retracted is 40.25” (102 cm), mounting
point to mounting point.
POWER
• The PRO-SW3000 system is
powered by a 12 Volt DC / 7.0
amp hour, sealed, rechargeable
battery.
• Battery charge maintained by a
120 V AC/60 Htz input and 18
V AC at 40 VA. output, transformer
rectified to 14 V DC through the
GTO
®
Control Board.
NOTE: Transformer should never
be connected directly to any battery.
• OPTIONAL: GTO/PRO
®
Solar
Panel Charger: float voltage 14.5
V DC output from a 19-3/8” (49.21
cm) x 15-1/4” (38.74 cm) silicon
alloy panel. Generates minimum
of 10 Watts at 600 mA. A gated
diode on the control board pre-
vents battery discharge.
• OPTIONAL: PRO-SW3200 slave
operator used with SW3000 in
dual gate applications with 40’
power cable.
CONTROLS
• The GTO/PRO
®
control board can be
programmed for pull-to-open or
push-to-open.
• Adjustable auto close, obstruction
sensitivity and dual gate sequencing.
• Slow Start/Stop for added cycles and
system life.
OPERATIONAL CAPACITY
The PRO-SW3000/SW3200 will handle
gates weighing up to 650 lbs. (295 kg)
and up to 16 ft. (4.88 m) in length (per
leaf) if all proper installation procedures
have been followed. Note that ball
bearing hinges should be used on all
gates weighing over 250 lbs (113.4 kg).
• Auto-memorization of digital
transmitter code.
• Charging regulated circuit on
control board. “Sleep draw” is
40 mA; “active draw” is 2 to 7
amps.
PROUDLY MADE
IN THE USA
BY GTO, Inc.
• GTO/PRO
®
remote-mounted RF
receiver tuned at 318 MHz.
Available Through:
Gate Weight
Gate Length
Number of Cycles Per Day
GTO/PRO SW3000 Gate
Capacity / Cycle Chart
Estimated number of daily cycles, based on use with a transformer
and one(1) 12 Volt battery.
650 lbs.
500 lbs.
400 lbs.
300 lbs.
200 lbs.
150 lbs.
100 lbs.
50 lbs.
120
130
140
150
160
170
180
190
5’ - 10’
110
120
130
140
150
160
170
180
12’
100
110
120
130
140
150
160
170
14’
90
100
110
120
130
140
150
160
16’