User Guide

Technical Specifi cations
SW
We are professional access system specialists
DC SERIES
Visit us on the web: www.gtopro.com
GTO® and GTO/PRO® are registered trademarks of GTO, Inc. © 2006, Rev. 9/16/06 PRO2500-CS
PRO-SW2500
DRIVE
• Powered by a reliable 12 Volt DC motor,
64:1 planetary gear drive system.
• Temperature rating of motor: -5° F
(-28° C ) to +160° F ( 71° C).
• Opening time is 20-24 seconds.
• Range of arm stroke is up to 22”
(56 cm). Operator length
with arm fully
retracted is 40.25” (102 cm), mounting
point to mounting point.
POWER
• The PRO-SW2500 system is
powered by a 12 Volt DC / 7.0
amp hour, sealed, rechargeable
battery.
• Battery charge maintained by a
120 V AC/60 Htz input and 18
V AC at 40 VA. output, transformer
rectifi ed to 14 V DC through the
GTO
®
Control Board.
NOTE: Transformer should never
be connected directly to any battery.
• OPTIONAL: GTO/PRO
®
Solar
Panel Charger: fl oat voltage 14.5
V DC output from a 19-3/8” (49.21
cm) x 15-1/4” (38.74 cm) silicon
alloy panel. Generates minimum
of 10 Watts at 600 mA. A gated
diode on the control board pre-
vents battery discharge.
• OPTIONAL: PRO-SW2550 slave
operator used with SW2500 in
dual gate applications with 40 ft.
(12.2 m) power cable.
CONTROLS
• The GTO/PRO
®
control board can be
programmed for pull-to-open or
push-to-open.
• Adjustable auto close, obstruction
sensitivity and dual gate sequencing.
• Slow Start/Stop for added cycles and
system life.
OPERATIONAL CAPACITY
The PRO-SW2500/SW2550 will handle
gates weighing up to 500 lbs. (226.8 kg)
and up to 16 ft. (4.9 m) in length (per
leaf) if all proper installation procedures
have been followed. Note that ball
bearing hinges should be used on all
gates weighing over 250 lbs (113.4 kg).
• Auto-memorization of digital
transmitter code.
• Charging regulated circuit on
control board. “Sleep draw” is
40 mA; “active draw” is 2 to 7
amps.
• GTO/PRO
®
remote-mounted RF
receiver tuned at 318 MHz.
Gate Weight
Gate Length
Number of Cycles Per Day
PRO SW2500 Gate Capacity / Cycle Chart
Estimated number of daily cycles, based on use with a transformer and one(1) 12 Volt battery.
500 lbs (226.8 kg)
400 lbs (181.4 kg)
300 lbs (136.6 kg)
200 lbs (90.7 kg)
150 lbs (68. kg)
100 lbs (45.4 kg)
50 lbs (22.7 kg)
165
175
185
195
205
215
225
6’
(1.8 m)
155
165
175
185
195
205
215
8’(2.4 m)
145
155
165
175
185
195
205
10’(3.1 m)
135
145
155
165
175
185
195
12’(3.7 m)
125
135
145
155
165
175
185
14’(4.3m)
100
125
135
145
155
165
175
16’(4.9 m)
Available Through:
PROFESSIONAL ACCESS SYSTEMS
®