DDP-60 ELECTRONICALLY CONTROLLED WATER DELIVERY PUMP w w w. g r o w on i x . c o m Built in the U.S.A. www.growonix.com toll free 888.406.8521, office 818.510.0264, sales@growonix.
INTRODUCTION OUR MISSION Durability, Reliability, Efficiency, Purity, and Conservation form the foundation on which we design and build all of our products. Consistent and superior quality sets us apart from other manufacturers and increases our value to you - our customer. Whether you are a hydroponics hobbyist, serious enthusiast, or large-scale gardener, GrowoniX is committed to bringing you the best solution for water purification systems.
FEATURES 60 GPM water flow rate Stack multiples for added Flow Rate Auto Shut-Off Circuitry under 0.7GPM.. High pressure cutoff. Ultra quiet and compact. Perfect for big water transfer. Perfect booster for CX Series RO systems. Constant duty. WHY USE A GROWONIX DDP-60? • To raise the water pressure on a water filtration system. • To transfer water from tank to tank. • To raise the pressure on any water appliance that flows from between 5-60 GPM @ 55psi. • To supply a faucet, shower, or hose bib.
particles. I. Product incorrect installation or operation are not covered by the warranty. The TQ series are designed for the pumping of non-aggressive water, or water not containing solid II. Operating conditions: particles. I. Product INSTRUCTIONS The TQ series are designed for the pumping of non-aggressive water, or water not containing solid 1. Ambient temp.conditions: : Max. +104ºF (40ºC) II. Operating Pleaseparticles.
IV. Piping 1. The suction line should be installed as short and straight as possible, with a minimum of bends. The internal diameter of the suction pipe must be equal to, or greater than the ports of the IV. PIPING pump. 1. The suction line should be installed as short and straight as possible, with a minimum of bends. 2.
INSTRUCTIONS CONT. ly applied city pressure can exceed pump operating pressure and damage the p 2. Flooded Suction -from city water supply 1.
ELECTRICAL This mark located outside the connection box is a warning for an electrical hazard. 1. Ensure the mains voltage is the same as the value shown on the motor plate and that the pump is safely connected to ground/earth. 2. The single phase models are supplied with plug and lead and can be connected directly to the mains supply. The 3 phase models should hook up with a circuit breaker. WARNING Risk of electric shock - This pump has not been investigated for use in swimming pool or marine areas.
INSTRUCTIONS CONT. PRECAUTIONS Precautions 1. The pump should IX. be shut-down and the trouble corrected if the pump is running at speed and found 1. The pump should be shut down and the trouble corrected if the pump is running at speed and to have any of the following problems: found to have any of the following problems: - No- liquid discharged - Not enough liquid discharged • No liquid discharged Not enough liquid discharged - Excessive • Excessive vibration - Motor vibration runs hot- Motor runs hot 2.
FREQUENTLY ASKED QUESTIONS 1. WHAT CAUSES THE DDP-60 TO START? The DDP-60 has the built-in pressure switch and internal flow switch. Each of these can turn the pump on depending on water consumption. The pump will start when: • The pressure is BELOW the pressure switch activation point. OR • The flow rate is greater than 0.7 GPM. 2. WHAT CAUSES THE DDP-60 TO STOP? The flow switch is designed to automatically stop the DDP-60 when flow drops to below 0.7 GPM. The DDP60 is programmed to stop after 8 seconds.
SPECIFICATIONS mensions: (in.) DIMENSIONS (INCHES) 400/800 Outlet NPT 1" 7.74 3.96 1.77 C Inlet NPT 1" 8.88 5.71 3.35 6.89 B 4-Ø0.4 A DDP-60: (A)13.23” (B) 5.08” 0/2200/3700 10 5.12 6.3 (C) 5.28” Model A (in.) B (in.) C (in.) TQ 200 13.23 5.08 5.28 TQ 400 13.56 5.43 5.
GROWONIX SYSTEM WARRANTY For a period of one year from the date of original purchase, we will replace or repair any part of the GrowoniX product that we find to be defective in operation due to faulty materials or workmanship with the exception of the replaceable filters and membranes.
DDP-60 ELECTRONICALLY CONTROLLED PUMP INSTRUCTION MANUAL w w w. g r o w on i x . c o m Built in the U.S.A.
