Installation Manual
7
V
IOLATION
OF
EPA
REGULATIONS
MAY
RESULT
IN
FINES
OR
OTHER
PENALTIES
.
NOTICE
CAUTION
Damage to the unit caused by operating the
compressor with the suction valve closed is not
covered under the warranty and may cause serious
compressor damage.
fInal charge adjuStment
The outdoor temperature must be 60°F or higher. Set the
room thermostat to COOL, fan switch to AUTO, and set the
temperature control well below room temperature.
After system has stabilized per startup instructions, check
subcooling and superheat as detailed in the following section.
SUCTION PRESSURE
PSIG R-22 R-410A
50 26 1
52 28 3
54 29 4
56 31 6
58 32 7
60 34 8
62 35 10
64 37 11
66 38 13
68 40 14
70 41 15
72 42 16
74 44 17
76 45 19
78 46 20
80 48 21
85 50 24
90 53 26
95 56 29
100 59 31
110 64 36
120 69 41
130 73 45
140 78 49
150 83 53
160 86 56
170 90 60
SATURATED SUCTION PRESSURE
TEMPERATURE CHART
SATURATED SUCTION
TEMPERATURE ºF
expanSIon valve SyStem
T
O
PREVENT
PERSONAL
INJURY
,
CAREFULLY
CONNECT
AND
DISCONNECT
MANIFOLD
GAUGE
HOSES
. E
SCAPING
LIQUID
REFRIGERANT
CAN
CAUSE
BURNS
. D
O
NOT
VENT
REFRIGERANT
INTO
THE
ATMOSPHERE
. R
ECOVER
ALL
REFRIGERANT
DURING
SYSTEM
REPAIR
AND
BEFORE
FINAL
UNIT
DISPOSAL
.
CAUTION
NOTE: Units matched with indoor coils equipped with
non-adjustable TXV should be charged by subcooling
only.
Run the unit on low stage cooling for 10 minutes until re-
frigerant pressures stabilize. Use the following guidelines
and methods to check unit operation and ensure that the
refrigerant charge is within limits. NOTE: Charge the unit
on low stage.
1. Purge the gauge lines and connect the service gauge
manifold to the base valve service ports.
2. Clamp a pipe clamp thermometer on the liquid line
near the liquid line service valve and 4-6” from the
compressor on the suction line.
a. Ensure the thermometer makes adequate contact
to obtain the best possible readings.
b. The temperature read with the thermometer should
be lower than the saturated condensing temperature.
LIQUID PRESSURE
PSIG
R-22
R-410A
200
101
70
210
105
73
220
108
76
225
110
78
235
113
80
245 116 83
255 119 85
265 121 88
275 124 90
285 127 92
295 130 95
305 133 97
325 137 101
355 144 108
375 148 112
405 155 118
415 157 119
425 n/a 121
435 n/a 123
445 n/a 125
475 n/a 130
500 n/a 134
525 n/a 138
550 n/a 142
575 n/a 145
600 n/a 149
625 n/a 152
SATURATED LIQUID PRESSURE
TEMPERATURE CHART
SATURATED LIQUID
TEMPERATURE ºF