Installation Manual

3
REPLACEMENT PARTS
ORDERING PARTS
When reporting shortages or damages, or ordering repair parts, give
the complete unit model and serial numbers as stamped on the unit’s
nameplate.
Replacement parts for this appliance are available through your
contractor or local distributor. For the location of your nearest
distributor, consult the white business pages, the yellow page section
of the local telephone book or contact:
CONSUMER AFFAIRS
GOODMAN MANUFACTURING COMPANY, L.P.
7401 SECURITY WAY
HOUSTON, TEXAS 77040
877-254-4729
SAFETY INSTRUCTIONS
The following symbols and labels are used throughout this manual to
indicate immediate or potential safety hazards. It is the owner’s and
installer’s responsibility to read and comply with all safety information
and instructions accompanying these symbols. Failure to heed safety
information increases the risk of personal injury, property damage,
and/or product damage.
WARNING
DO NOT CONNECT TO OR USE ANY DEVICE THAT IS NOT DESIGN-CERTIFIED
BY
GOODMAN FOR USE WITH THIS UNIT. SERIOUS PROPERTY DAMAGE,
PERSONAL INJURY, REDUCED UNIT PERFORMANCE AND/
OR HAZARDOUS
CONDITIONS MAY RESULT FROM THE USE OF SUCH NON-APPROVED DEVICES.
WARNING
HIGH VOLTAGE!
DISCONNECT ALL POWER BEFORE SERVICING OR INSTALLING
THIS UNIT.
MULTIPLE POWER SOURCES MAY BE PRESENT. FAILURE
TO DO SO MAY CAUSE PROPERTY DAMAGE, PERSONAL INJURY OR
DEATH.
WARNING
CONNECTING UNIT DUCT WORK TO UNAUTHORIZED HEAT PRODUCING DEVICES
SUCH AS A FIREPLACE INSERT, STOVE, ETC. MAY RESULT IN PROPERTY
DAMAGE, FIRE, CARBON MONOXIDE POISONING, EXPLOSION, PERSONAL
INJURY OR DEATH.
WARNING
T
HIS PRODUCT CONTAINS OR PRODUCES A CHEMICAL OR CHEMICALS WHICH
MAY CAUSE SERIOUS ILLNESS OR DEATH AND WHICH ARE KNOWN TO THE
S
TATE OF
C
ALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER
REPRODUCTIVE HARM.
WARNING
T
O AVOID PROPERTY DAMAGE, PERSONAL INJURY OR DEATH, DO NOT USE
THIS UNIT IF ANY PART HAS BEEN UNDER WATER.
I
MMEDIATELY CALL A
QUALIFIED SERVICE TECHNICIAN TO INSPECT THE FURNACE AND TO REPLACE
ANY PART OF THE CONTROL SYSTEM AND ANY GAS CONTROL HAVING BEEN
UNDER WATER.
WARNING
TO PREVENT THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH,
DO NOT STORE COMBUSTIBLE MATERIALS OR USE GASOLINE OR OTHER
FLAMMABLE LIQUIDS OR VAPORS IN THE VICINITY OF THIS APPLIANCE.
CODES AND REGULATIONS
The *PC/*PH M-series air conditioners and heat pumps are designed
for OUTDOOR USE ONLY. *PH M-Series is available in cooling ca-
pacities of 2, 2-1/2, 3, 3-1/2, 4 and 5 nominal tons of cooling. *PC M-
Series is available in cooling capacities of 2,
2-1/2, 3, 3-1/2, 4 and 5 nominal tons of cooling. Optional field
installed heat kits are available in 5, 8, 10, 15 and 20 kW. The units
can be easily installed in manufactured or modular homes with
existing high-static duct work. The units can also be easily con-
verted to accommodate a plenum for normal or low-static applica-
tions. The *PC/*PH M-series are self contained packaged units so
the only connections needed for installation are the supply and
return ducts, the line and low voltage wiring and drain connection.
Rated performance is achieved after 20 hours of operation. Rated
performance is delivered at the specified airflow. See outdoor unit
specification sheet for split system models or product specification
sheet for packaged and light commercial models. Specification sheets
can be found at
www.goodmanmfg.com for Goodman
®
brand prod-
ucts or www.amana-hac.com for Amana
®
brand products. Within
either website, please select the residential or commercial products
menu and then select the submenu for the type of product to be
installed, such as air conditioners or heat pumps, to access a list of
product pages that each contain links to that model’s specification
sheet.
The information on the rating plate is in compliance with the FTC &
DOE rating for single phase units. The efficiency ratings of these
units are a product of thermal efficiency determined under continu-
ous operating conditions independent of any installed system.
EPA REGULATIONS
IMPORTANT: THE UNITED STATES ENVIRONMENTAL PROTECTION
AGENCY (EPA) HAS ISSUED VARIOUS REGULATIONS REGARDING THE
INTRODUCTION AND DISPOSAL OF REFRIGERANTS IN THIS UNIT.
FAILURE TO FOLLOW THESE REGULATIONS MAY HARM THE
ENVIRONMENT
AND CAN LEAD TO THE IMPOSITION OF SUBSTANTIAL
FINES. BECAUSE REGULATIONS MAY VARY DUE TO PASSAGE OF NEW
LAWS
, WE SUGGEST A CERTIFIED TECHNICIAN PERFORM ANY WORK
DONE
ON THIS UNIT. SHOULD YOU HAVE ANY QUESTIONS PLEASE
CONTACT
THE LOCAL OFFICE OF THE EPA.
NATIONAL C ODES
This product is designed and manufactured to permit installation
in accordance with National Codes. It is the installer’s responsi-
bility to install the product in accordance with National Codes and/
or prevailing local codes and regulations.