Owner manual

ManualsBrandsGlastender ManualsWater equipmentWR

Operation Manual, Parts Directory, and Price List

Rev. 07-01-14

BB60-L1-XSH(LR)

*Cooler Serial Number iNformatioN

This manual is specic to:

• Self-contained BB and ND coolers

purchased in 2009 and after beginning with

the listed serial numbers and dates below and

to the right

• KC coolers per list to the right

• All BB and ND Two Zone Coolers

BB60R 134121363F 02/26/09

BB60L 134121425F 03/03/09

BB84R 134121457F 03/04/09

BB84L 134121456F 03/04/09

BB108R 134121452F 03/04/09

BB108L 134121226F 02/17/09

ND52R 134121519F 03/09/09

ND52L 134121559F 03/11/09

ND72R 134121906F 04/08/09

ND72L 134121475F 03/11/09

ND92R 134121126F 02/09/09

ND92L 134122745F 06/10/09

KC60 134124073N 09/21/09

KC84 All units with S/N’s N/A

beginning with 134

KC108 All units N/A

bb*, ND*, aND KC* CoolerS

BB60, BB84, BB108, ND52, ND72, ND92, KC60, KC84, KC108

bb & ND two ZoNe CoolerS

BB60BW, BR, WR, BB84BW, BR, WR, BB108BW, BR, WR, ND52BW, BR, WR,

ND72BW, BR, WR, ND92BW, BR, WR

ND72-R1-GS(LRL)

Glastender, Inc. · 5400 North Michigan Road · Saginaw, MI · 48604-9780

800.748.0423 · 989.752.4275 · Fax 989.752.4444 · www.glastender.com

A Family Company Manufacturing

In The USA Since 1969

4004503

Conforms to UL STD 471

Certied to CAN/CSA STD

C22.2 No. 120-M91

KC60-R1-SS(LR)

Summary of content (13 pages)

PAGE 1
Operation Manual, Parts Directory, and Price List A Family Company Manufacturing In The USA Since 1969 BB*, ND*, and KC* Coolers BB60, BB84, BB108, ND52, ND72, ND92, KC60, KC84, KC108 BB & ND Two Zone Coolers BB60BW, BR, WR, BB84BW, BR, WR, BB108BW, BR, WR, ND52BW, BR, WR, ND72BW, BR, WR, ND92BW, BR, WR *Cooler Serial Number Information This manual is specific to: • Self-contained BB and ND coolers purchased in 2009 and after beginning with the listed serial numbers and dates below and to the right • K
PAGE 2
Index Cooler Serial Number Information. ......................... Cover Digital Controller Operation............................................2 Installation Introduction........................................................................3 Utility Requirements and Connections..............................3 Uncrating and Start-Up Instructions..................................3 Operation............................................................................3 Cleaning Instructions....................
PAGE 3
Digital Controller Operation The operating temperature range is preset at the factory according to the table below and can be adjusted up or down within the limits shown. To see the set point - push and immediately release the SET button. The set point will be displayed. To return to normal visualization - Push and immediately release the SET button or wait five seconds. To change the set point - push and hold the SET button for more than two seconds.
PAGE 4
Installation Introduction This manual describes the operational features of self-contained BB60, BB84, BB108, ND52, ND72, and ND92 coolers and two zone coolers. Please review this information before attempting installation and operation. Long term, trouble-free service will follow if good housekeeping and maintenance procedures are followed. Thank you for selecting Glastender, Inc. products. Utility Requirements and Connections • Electrical: 115 Volt AC, 1 Phase, 60 Hz.
PAGE 5
Installation (Cleaning Instructions continued from page 3) PROCEDURE: Cleaning condenser filter: 1. A non-chlorine based cleaner or mild detergent and warm water applied with a soft cloth or sponge to all contact surfaces. 2. Immediately rinse off cleaning agent(s), using clean warm water, clean soft cloth or sponge. 3. Dry with a soft clean cloth, removing standing water as soon as possible. 4. Condenser filter - remove small louvered covers only.
PAGE 6
Installation Attention Installer: WARNING!! Failure to level this cooler WILL VOID THE FACTORY WARRANTY. Doors will not close properly causing damage to hinges, handles, and/or gaskets which will adversely affect the refrigeration systems.
PAGE 7
Electrical and Refrigeration Specifications All Models Electrical Refrigerant Pressure P.S.I.G 120V, 1 phase, 60 Hz, 6.5 full load amps, 1/4 HP Type R134a, Charge 16.0 oz. High 350, Low 88 Wiring Diagram Glastender, Inc. • 5400 North Michigan Road • Saginaw, MI • 48604-9780 800.748.0423 • 989.752.4275 • Fax 989.752.4444 • www.glastender.
PAGE 8
Compressor and Condenser Related Parts Part No. 11000084 06001382 04000243 06001303 06001445 06001395 06004180 06001393 06006088 06001385 06000846 07000234 06001350 06000845 06003950 06003951 16. 06001313 06006096 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11. 12. 13. 14. 15.
PAGE 9
Evaporators and Related Parts Part No.
PAGE 10
Doors and Related Parts Part No.
PAGE 11
Refrigeration Compartment Covers Part No.
PAGE 12
Warranty Statement APPLICABLE TO ALL PRODUCTS SOLD WITHIN THE UNITED STATES AND CANADA LABOR: Glastender, Inc. warrants all products to be free of defects in material and workmanship. In established areas, a start-up is included with glasswasher models GT-24 and GT-30. A 1-year labor warranty applies to all glasswashers.
PAGE 13
Terms and Conditions Prices: All prices are LIST. Applicable taxes will be added. Quotations: Unless otherwise stated, quotations are effective for 30 days only. Acceptance: All orders are subject to acceptance by Glastender, Inc.’s headquarters in Saginaw, Michigan. Possession of the Product Directory and Price List is not an offer to sell. Shipments: F.O.B. factory in Saginaw, Michigan. Freight terms are Third Party or Collect if shipped directly to you.