Manualshelf

Use and Care Manual

ManualsBrandsGhostshield ManualsPaint1 Gal. Non-acid Based Concrete Etcher and Cleaner
123
!
Technical Data Sheet
1001
PRODUCT DATA
TECHNOLOGY // ADVANTAGES
•
Etches concrete - cleans and give porosity before sealing
•
Concentrated - "one gallon makes up to three (3) gallons
•
100% biodegradable - "safe, non-acid based cleaner
•
No odor - "no smell, not a skin irritant, non-corrosive
•
No neutralizing - "no required neutralizing step after etching
•
Fast-acting formula - "safely use on interior and exterior
applications
•
Eliminates need to use harsh chemicals - "provides a safer work
environment.
•
Increases the life of concrete equipment - "can be used to clean
and remove light concrete build up from tools and equipment as
well as mortar from bricks and tools.
•
Can be used straight or diluted - "A maximum 2 parts water : 1
part Eco-Etch 1001 ratio may be used
TYPICAL PROPERTIES!
Appearance - Yellowish, clear liquid!
Packaging - 1 gallon concentrate (3.78 L), 55 gallon (208 L) drums
Reconstitution:
1. Only mix with water. Mix solution slowly in an open-top plastic
container. Stir gently. Ratio varies by desired use: for a lighter etch,
two (2) parts water to one (1) part Eco-Etch 1001; for a medium etch,
one (1) part water to one (1) part Eco-Etch 1001 and for a heavier
etch, full strength.
Application
1. Always test a small area before application to ensure desired ratio,
etch time, coverage rates and to verify application technique.
2.Before cleaning or etching, make sure the concrete is free of all oil,
contaminants, grease, dirt and rust stains (will not clean grease, oil or
rust spots).
3. First wet the substrate with water. Apply using a low-pressure
pump sprayer. Allow the solution to sit on the substrate for three (3)
to ten (10) minutes. Flush throughly with clean water. You do not
need to neutralize after using Eco-Etch 1001.
Clean Up
Clean equipment and tools with hot soapy water. Unused or old
material may be disposed of in a waste disposal site in accordance
with local, state and federal laws.
2
Sections
03
03 91 00
Concrete Cleaning