Technical Specifications

THEORETICAL YIELD
per 10.3 fl. oz. cartridge
Joint Size Linear Feet
1/4” x 1/4” 24.8
1/4” x 3/8” 16.5
1/4” x 1/2” 12.4
1/2” x 3/8” 8.7
1/2” x 1/2” 6.2
3/4” x 1/2” 4.1
7. MAINTENANCE:
No maintenance should be
required. If the sealant is
damaged, either remove bead
and reseal with Ultima Roof
Sealant or apply additional
Ultima Roof Sealant over the
damaged area.
8. TECHNICAL SERVICES:
we will either replace the product
at no cost or refund the original
purchase price for that portion of
product that fails to perform in
accordance with this limited
warranty. Labor or costs
associated with labor are not
included. THIS LIMITED
WARRANTY IS IN LIEU OF ALL
OTHER WARRANTIES, EXPRESS
OR IMPLIED, INCLUDING
MERCHANTABILITY, WHICH ARE
ALL DISCLAIMED AND/OR
LIMITED IN DURATION TO THE
EXTENT PERMITTED BY LAW. WE
SHALL NOT BE LIABLE FOR
INDIRECT, SPECIAL, INCIDENTAL
OR CONSEQUENTIAL DAMAGES
(INCLUDING LOST PROFITS)
FROM ANY CAUSE WHATSOEVER
AND SUCH DAMAGES ARE
EXPRESSLY EXCLUDED. Some
states do not allow the exclusion
or limitation of incidental or
consequential damages or how
long an implied warranty lasts, so
the above limitation or exclusion
may not apply to you. This limited
warranty gives you specific legal
rights, and you may also have
other rights which vary from state
to state.
MEK to clean joints or to remove
surface coatings unless surface
can be allowed to dry before
application of sealant. If the joint is
wet with solvent, the sealant will
not adhere properly. Use of a dry
rag or brush to remove dust, dirt,
or other contaminants is
recommended. Contamination
from curing agents and form
releases should be avoided.
Contact Geocel Products Group's
Technical Service Department or
representative if such agents are
involved.
Elongation: 1062%
Tack Free: 45 minutes
Cure: 4 days
Joint Backing: Joint depth should
not exceed 3/8". An open cell
backer rod should be used to
control joint depth. In shallow
joints, a bond breaker tape should
be installed to prevent three-point
contact.
Application and Tooling: Apply
with conventional caulking
equipment, filling joint completely.
When temperature is below 40° F,
application will be easier if sealant
is warmed. When temperature of
surface to be sealed exceeds 140°
F, do not apply sealant until surface
cools. A soap solution or a solvent
such as xylene may be used as a
lubricant for tooling. Do not allow
tooling agents to contaminate
open joints.
Painting:Sealant may be painted
after 24 hours. If using a relatively
inflexible paint, allow sealant to
cure for 3 days before painting.
Ultima Roof Sealant may be
coated with any latex and most
oil-based paints. Some paints may
crack in dynamic joints. See paint
manufacturer's specifications.
Cleaning: Remove Ultima Roof
Sealant from gun and tools before
it cures. This may be done by
scraping and use of solvents such
as MEK (lacquer thinner), xylene,
Toluol or chlorinated solvents.
Cured materials may be removed
by cutting with sharp tools.
Observe manufacturer's
precautions when using toxic or
flammable solvents.
Storage Life: One year
Cautions: Contains AROMATIC
HYDROCARBONS. Contents are
COMBUSTIBLE. Keep away from
heat and open flame. VAPOR
HARMFUL. Use only with
adequate ventilation. To avoid
overexposure, open windows and
doors or use other means to
ensure fresh air entry during
application and drying. If you
experience eye watering,
headaches, or dizziness, increase
fresh air, or wear respiratory
protection (NIOSH approved) or
leave the area. Avoid contact with
eyes and skin. Wash hands after
using. Keep container closed
when not in use. Do not transfer
contents to other containers for
storage.
First Aid: In case of eye contact,
flush thoroughly with large
amounts of water for 15 minutes
and get medical attention. For
skin contact, wash thoroughly
with soap and water. In case of
respiratory difficulty, provide fresh
air and call physician. If
swallowed, call Poison Control
Center, hospital emergency room,
or physician immediately.
DELAYED EFFECTS FROM LONG
TERM OVEREXPOSURE.
Contains solvents which can
cause permanent brain and
nervous system damage.
Intentional misuse by deliberately
concentrating and inhaling the
contents can be harmful or fatal.
Warning: This product contains
chemicals known to the State of
California to cause cancer and
birth defects or other reproductive
harm. DO NOT TAKE
INTERNALLY. KEEP OUT OF THE
REACH OF CHILDREN.
Geocel Products Group
representatives throughout the
United States are available to
provide technical assistance.
Geocel Products Group's
in-house technical staff and
laboratory facilities are
equipped to respond to
specific requests for further
information and/or applications
testing.
Available from various construction
material and industrial distributors.
Cost and further technical data are
availabe from your local Geocel
Products Group representative or
from our office.
5. AVAILABILITY AND COST:
©2015 Geocel Products Group
A Business Unit of The Sherwin-Williams Company
710126 1115
REGISTERED
O
9001 • 14001
Setting the Standard
®
Cleveland, OH 44115
[phone]
Fax [phone]
www.GeocelUSA.com
6. LIMITED WARRANTY:
If when applied according to label
directions this product fails to
perform in accordance with its
published literature, upon
satisfactory evidence of product
failure, and as your sole remedy,