Product Manual A
Table Of Contents
- Table of Contents
- Safety
- General Information
- Operation
- Light Tower Set Up
- Raising the Mast
- Raising the Mast with Electric Winch Option
- Starting the Unit
- Light Operation
- Derating for Altitude
- Wet Stacking
- Control Panel Receptacles
- Shutting Down the Unit
- Automatic Shutdown
- Lowering the Mast - Manual
- Lowering the Mast - Electric Winch Option
- Towing the Unit
- Lifting and Tie Down
- Maintenance
- Troubleshooting
- Wiring Diagrams
- Options & Accessories
- Service Log
- Notes
Maintenance
17973 G MLT6SM/K-8SK Operating Manual 29
BASIC MAINTENANCE SCHEDULE - KUBOTA ENGINE
Refer to the original equipment manufacturer’s operating manual for a complete list of
maintenance requirements. Failure to comply with the procedures as described in the engine
operator’s manual will nullify the warranty, decrease performance and cause equipment
damage or premature equipment failure. Maintenance records may be required to complete
a warranty request.
Use the schedule in the following table as a guide for regular maintenance intervals. For additional or replacement
copies of the engine operator’s manual, contact an authorized dealer in your area.
* Change the engine oil and oil filter after the initial 50 hours of operation, then at the appropriate interval thereafter.
** Replace the air cleaner element yearly, or after six cleanings, whichever occurs first.
WINCH USE, OPERATION AND MAINTENANCE - MANUAL
Prior to Use
• Inspect rope or cable and replace if damaged.
• Check mounting hardware for proper tightness and re-torque if necessary.
• Gears, ratchet pivot point and shaft bushings must be kept lubricated with a thin film of oil or grease.
Operation
Lifting the Lights:
1. The cable must be securely fastened to the object being lifted and to the winch drum.
2. Always be sure that the cable and cable attachments are not damaged and are strong enough for the load.
Ensure there is an adequate safety factor of at least three times the maximum load for all components used.
Item Daily
50
Hours
250
Hours
500
Hours
As
Required
Check Oil Level
Check Coolant Level
Check Fuel Level
Check Tire Pressure
Check All Electrical Connections
Inspect Radiator Fins For Debris, Clean As Required
Inspect Light Tower Winch For Proper Operation
Check Fan Belt Tightness
Check Radiator Hoses And Clamp Bands *
Change Engine Oil *
Replace Oil Filter Cartridge *
Replace Fuel Filter Cartridge
Replace Air Filter Element **
Replace Fan Belt
Lubricate Leveling Jacks
Remove Sediment In Fuel Tank
Clean Air Cleaner Element