Spec Sheet

ManualsBrandsGenerac ManualsEngine Driven Full Trash PumpsDiesel Dry Prime Mobile Full Trash Pump — 1,450 GPM, 4in. Ports, Tier 4 Final Approved

Generac Mobile Products LLC l 800-926-9768 l 920-361-4442 l www.generacmobileproducts.com

Page 1 of 4

MTP4DZV

ENGINE

• Deutz TD 2.9 L4 – water-cooled, naturally aspirated diesel engine

o 49 hp @ 2600 rpm

o 4 cylinder

o 2.9 Liter displacement

o DOC only for exhaust after treatment

o EPA Final Tier 4 approved

o Steel, single wall fuel tank

 113 gal. (428 L) capacity / 100 gal. (379 L) usable

• Fuel consumption at prime: 100% - 2.93 gph (11.1 Lph)

• Cooling system capable of operating at 120ºF (49ºC) ambient

• Disposable air filter – paper element

• 950 CCA wet cell battery

• 95 Amp alternator

• Low coolant warning/shutdown

PUMP

• Cornell 4NNTL, Venturi Dry Prime Centrifugal Pump

• Bendix compressor flow up to 13.2 CFM

• 4 in. NPTF – suction & discharge connection

• Cast Iron ASTM A48 Class 30 pump casing

• Cast Iron ASTM A48, Class 30 impeller

• 2 vane, enclosed impeller

• Impeller design incorporated with deflector vanes and pump out vanes

• Single mechanical seal, John Crane Type 1 & 2, with tungsten carbide vs silicon carbide faces

• Replaceable wear ring

• Run-dry system for continuous operations without need for external flush water or venting

• Pump shaft - 1144 stress-proof steel

SPECIFICATIONS

VENTURI DRY PRIME

MOBILE TRASH PUMP

with Enclosure Option

Summary of content (4 pages)

PAGE 1
MTP4DZV VENTURI DRY PRIME MOBILE TRASH PUMP with Enclosure Option SPECIFICATIONS ENGINE • • • • • • • Deutz TD 2.9 L4 – water-cooled, naturally aspirated diesel engine o 49 hp @ 2600 rpm o 4 cylinder o 2.9 Liter displacement o DOC only for exhaust after treatment o EPA Final Tier 4 approved o Steel, single wall fuel tank  113 gal. (428 L) capacity / 100 gal. (379 L) usable Fuel consumption at prime: 100% - 2.93 gph (11.
PAGE 2
MTP4DZV MOBILE TRASH PUMP SPECIFICATIONS PUMP PERFORMANCE • • • • • • • • Pump output – 1450 gpm (5489 Lpm) Lift suction – 28 ft. (8.5 m) Maximum diameter of solids – 3 in. (76.2 mm) Impeller diameter: 8.25 in. (20.9 cm) Maximum efficiency (BEP Percent) – 80% BEP Flow – 870 gpm (3,293 Lpm) @ 107ft. TDH Total dynamic head – 165 ft. (50.29 m) Intake/Discharge height – 29 in. (73.7 cm) Duty Points: o 700 gpm (2650 Lpm) @ 60 ft. (18.3 m) TDH @ 1800 RPM, 78% efficiency, NPSHR 10 ft. (3.
PAGE 3
MTP4DZV MOBILE TRASH PUMP SPECIFICATIONS SYSTEM CONTROLS • • White LED lighting control panel lighting Standard controller – LOFA CP750 o Large, backlit 4.3 in. (109 mm) LCD display  Displays engine temp, engine speed, fuel level, engine hrs.
PAGE 4
MTP4DZV MOBILE TRASH PUMP SPECIFICATIONS ENCLOSURE OPTION • • • • • • • • Aluminum, sound attenuated enclosure; insulated and baffled Field fitment of enclosure without need to modify trailer UV & fade resistant, high temperature cured, white polyester powder paint Stainless steel hinges on all doors Fully lockable enclosure including doors and fuel fill Rear cabinet opens to allow for full access to pump and bearing frame for ease of service or pump replacement without needing to remove any cabinet or