LP Conversion Kit

Low setting adjustments must be made with other burners in
RSHUDWLRQRQDPHGLXPVHWWLQJ7KLVSURFHGXUHSUHYHQWVWKH
ORZÀDPHIURPEHLQJVHWWRRORZUHVXOWLQJLQWKHÀDPHEHLQJ
extinguished when other burners are turned on.
A. Turn on all surface burners to medium setting.
% 7XUQWKHNQRERQWKHEXUQHUEHLQJDGMXVWHGWR³/2´
& 5HPRYHWKHNQREDQGLQVHUWDVPDOOÀDWEODGHVFUHZGULYHU
LQWRWKHYDOYHVKDIWDQGRUVLGHDGMXVWPHQWVFUHZVDV
shown and turn clockwise to fully tighten down the bypass
VFUHZV5HSHDWIRUDOOYDOYHV
' ,IÀDPHDSSHDUVWRRORZRUXQVWDEOHVORZO\WXUQE\SDVVVFUHZ
FRXQWHUFORFNZLVHXQWLODVWDEOHÀDPHH[LVWVIRUHDFKEXUQHU
Remember, other burners must be turned on to medium.
SPECIALTY BURNERS
Multi-Ring Burner±7KHRXWHUULQJRIÀDPHVVKRXOGEH
DGMXVWHGZLWKWKHNQREDWWKH0('E\DGMXVWLQJWKHVHWVFUHZ
LQWKHFHQWHUYDOYHVKDIW7KHÀDPHVVKRXOGEHDGMXVWHGVR
WKDWWKH\EDUHO\FXUORYHUWKHWRSHGJHRIWKHEXUQHUFDS7KH
FHQWHUULQJRIÀDPHVVKRXOGEHDGMXVWHGZLWKWKHNQREDWWKH
/2VHWWLQJE\DGMXVWLQJWKHVHWVFUHZWRWKHULJKWRIWKHYDOYH
shaft.
ADDITIONAL INFORMATION
ADJUSTING AIR SHUTTER SETTINGS
FOR OVEN BURNERS
ADJUSTING LOW FLAME SETTING
ON COOKTOP BURNERS
2YHQEXUQHUÀDPHPXVWEHREVHUYHGZLWKWKHGRRUFORVHG
WRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
 &KHFNLQJWKHÀDPHVL]H
,WVKRXOGEHDSSUR[LPDWHO\
1/2” to 3/4” long for the bake
and broil burners.
The combustion quality of
WKHEXUQHUÀDPHVQHHGVWR
EHGHWHUPLQHGYLVXDOO\
SPECIAL NOTE:
To convert the oven back to natural gas, reverse the
instructions given in making propane adjustments.
PROPANE CONVERSION INSTRUCTIONS
31-2000752 Rev. 1 04-21 GEA
PGB965
NOTICE:
2QFHWKHFRQYHUVLRQLVFRPSOHWHDQGFRQ¿UPHG¿OORXW
WKHSURSDQHVWLFNHUDQGLQFOXGH\RXUQDPHRUJDQL]DWLRQ
DQGGDWHFRQYHUVLRQZDVPDGH$SSO\WKHVWLFNHUWRWKH
range near the regulator to alert others in the future that
WKLVDSSOLDQFHKDVEHHQFRQYHUWHGWRSURSDQH,IFRQYHUWLQJ
EDFNWRQDWXUDOJDVIURPSURSDQHSOHDVHUHPRYHWKHVWLFNHU
so others know the appliance is set to use natural gas.
BURNER OUTPUT RATINGS: BTU/HR
NG (Natural) Gas 5” W.C.P.
BURNER
BTU
RATE
ORIFICE
SIZE (in) COLOR MARKING
LF 20,000
LF1 N/A 0.043 Blue/White 109N
LF2 N/A 0.043 Blue/White 109N
LF3 N/A 0.043 Blue/White 109N
LFC N/A 0.025 None 63N
LR 5,000 0.040 :KLWH3XUSOH 101N
RF 18,000 0.078 3XUSOH 198N
RR 9,500 0.053 Green 136N
C 10,000 0.055 Yellow 140N
Upper Bake 7,000 0.046 Yellow 046N
Broil 16,500 0.071 Black/Blue 071N
Lower Bake 14,000 0.066 Red 066N
The air shutters should be turned to the marked settings NG or
propane or set according to the following table.
:LWKD3KLOOLSVKHDGVFUHZGULYHUORRVHQWKHVFUHZVVHFXULQJ
the air shutters on the burners and adjust the air shutters
according to chart.
%DNHDQGEURLOÀDPHVPXVWEHFKHFNHGZLWKWKHRYHQ
GRRUVFORVHGWRSURSHUO\FKHFNÀDPHFKDUDFWHULVWLFV
1. Turn on the gas.
2. Turn on the electricity.
 5HLQVWDOOWKHORZHURYHQGRRU&ORVHERWKGRRUV
4. Turn on both bake burners.
 )RUHDFKEXUQHUREVHUYHWKHIROORZLQJWKURXJKWKHRYHQ
door windows.
 D,IWKHÀDPHVDUH\HOORZRSHQWKHDLUVKXWWHUPRUH
 E,IWKHÀDPHVEORZDZD\RUÀXWWHUIURPWKHEXUQHUFORVH
the air shutter slightly, but not by more than 1/8”.
 7XUQEDNHEXUQHURႇDQGUHSHDWZLWKEURLOEXUQHU
BURNER
AIR SHUTTER
SETTING FOR PROPANE
AIR SHUTTER
SETTING FOR NG
/RZHU2YHQ
Broil
Burner
0.690 0.690
8SSHU2YHQ
Bake
Burner
0.750 0.750
/RZHU2YHQ
Bake
Burner
Full Open Full Open
Air Shutter
Setting
Air shutter
3KLOOLSV6FUHZ
WARNING
,I\RXDWWHPSWWRPHDVXUHWKHLQQHUFRQH
RIWKHÀDPHSOHDVHXVHFDXWLRQEXUQVFRXOGUHVXOW
198
III
Denotes 1.98mm Orifice size opening
Denotes Natural Gas
N
CONVERTING THE OVEN BURNERS
UPPER AND LOWER OVEN BAKE BURNER
ORIFICES
 5HPRYHWKHORZHURYHQGRRUIURPWKHXQLW
 5HPRYHRYHQUDFNVRYHQERWWRPVDQGÀDPHVSUHDGHUV
IURPERWKRYHQV,QWKHORZHURYHQUHPRYHWKHHQFORVXUH
around the rear of the bake burner held in place by three
3KLOOLSVVFUHZV
 5HPRYHDOO´KH[
screws securing the bake
burners. Gently slide
each bake burner to the
OHIWWRUHPRYHLWIURPWKH
RUL¿FHDQGDOORZEXUQHUV
to rest on the bottom of
WKHLUUHVSHFWLYHRYHQV
 :LWKD´ZUHQFKORRVHQHDFKRUL¿FHE\WXUQLQJFRXQWHU
FORFNZLVHDQGUHPRYH
 6HOHFWWKHDSSURSULDWHEDNHRUL¿FHIRUHDFKRYHQIURPWKH
NLWDQGLQVWDOORQWKHWKUHDGHG¿WWLQJV7LJKWHQZLWKZUHQFK
until snug.
 *HQWO\UHSODFHWKHEDNHEXUQHUVRYHUWKHLUUHVSHFWLYHRUL¿FHV
and replace all 1/4” hex screws securing the burners.
BROIL BURNER ORIFICE
 5HPRYHWKH´KH[
screw securing the broil
burner and allow it to
hang down free of the
EURLORUL¿FH
2. Apply a 1/2” wrench
to the hex base of the
RUL¿FH/RRVHQWKH
RUL¿FHE\WXUQLQJFRXQWHUFORFNZLVHDQGUHPRYH
 6HOHFWWKHSURSDQHEURLORUL¿FHIURPWKHNLWDQGLQVWDOOLWRQ
the broil elbow. Tighten until snug.
 5HSODFHWKHEURLOEXUQHURYHUWKHRUL¿FHDQGUHSODFHWKH
screw securing the burner.
NOTICE:
7KLVSURGXFWFDQQRWEHFRQYHUWHGWRSURSDQHE\DGMXVWLQJ
WKHRYHQRUL¿FHV7KHRUL¿FHVPXVWEHUHSODFHGIRUSURSDQH
127(,IEXUQHUÀDPHVORRNOLNH$IXUWKHUDLUVKXWWHU
adjustment to the bake buner is required. Normal
EXUQHUÀDPHVVKRXOGORRNOLNH%RU&GHSHQGLQJ
on the type of gas you use. With propane gas, some
yellow tipping on the outer cones is normal.
)RUHLJQSDUWLFOHVLQWKHJDVOLQHPD\FDXVHDQRUDQJHÀDPHDW
¿UVWEXWWKLVZLOOVRRQGLVDSSHDU
8. Retighten the air shutter screws.
9. When all adjustments are made and the results are
satisfactory:
a. Replace the enclosure around the rear of the bake
EXUQHULQWKHORZHURYHQ
 E5HSODFHWKHÀDPHVSUHDGHUV
 F5HSODFHWKHRYHQERWWRPVDQGRYHQUDFNV
(A) Yellow flames:
Further Adjustment
Required
(B) Yellow tips on
outer cones:
Normal for Propane Gas
(C) Soft blue flames:
Normal for Natural Gas
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
Broil
2UL¿FH
2YHQ
Light
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
Adjustment screws for
multi-ring burner only
Adjustment screw for outer ring
Adjustment screw
for center ring
Flames
Burner Cap
( 5HSODFHWKHNQRE
Center adjustment screw