LP Conversion Kit

(A) Soft blue flames—
Normal for natural gas
(B) Yellow tips on
outer cones—
Normal for propane gas
BURNER OUTPUT RATINGS: BTU/HR
Propane Gas 10” W.C.P.
BURNER
BTU
RATE
ORIFICE
SIZE (in) COLOR MARKING
LF 15,000
LF1 N/A 0.025 Blue/Blue 63L
LF2 N/A 0.025 Blue/Blue 63L
LF3 N/A 0.025 Blue/Blue 63L
LFC N/A 0.016 None 40L
LR 5,000 0.026 Red/Yellow 66L
RF 18,000 0.047 Red/Orange 119L
RR 9,500 0.035 Blue/Brown 89L
C 8,000 0.034 Orange/Green 86L
To adjust your range for use with propane gas, follow these
instructions:
1. Disconnect all electrical power, at the main circuit breaker or
fuse box.
6KXWRႇWKHJDVVXSSO\WRWKHUDQJHE\FORVLQJWKHPDQXDO
VKXWRႇYDOYH
CONVERTING THE PRESSURE REGULATOR
5HPRYHWKHGUDZHUDQGSDQHOEHKLQGGUDZHU7KHSUHVVXUH
regulator is located in the lower, left hand rear corner of the
UDQJHDVYLHZHGIURPWKHIURQW
1. Use an adjustable wrench to unscrew the hex-nut cap from
the pressure regulator.
 &RPSOHWHO\UHPRYHWKHSURWHFWLYHSODVWLFFDSRႇWKH
threaded metal cap.
 7XUQWKHPHWDOFDSVRWKHW\SHRIJDVEHLQJFRQYHUWHGWRLV
GLVSOD\HGDQGUHSODFHWKHSURWHFWLYHSODVWLFFRYHU
4. Screw the hex-nut cap back into the regulator.
(Do not over tighten)
TOOLS REQUIRED:
• Adjustable wrench
• Socket wrench with
1/2” socket and extension
• 3KLOOLSVKHDGVFUHZGULYHU
• )ODWEODGHGVFUHZGULYHU
(blade approximately
3/32” across)
• 1XWGULYHUV´´
or 7mm
Pressure Regulator *DV9DOYH
PROPANE
NAT
Rotate cap counter-
clockwise to loosen
Cap assembly
Regulator
WARNING
'RQRWRSHUDWHWKHFRRNWRSRURYHQ
burners of this range when using propane (bottled) gas
EHIRUHFRQYHUWLQJWKHSUHVVXUHUHJXODWRUDQGEXUQHURUL¿FHV
for propane gas use. Failure to do so could cause high
ÀDPHVDQGWR[LFIXPHVZKLFKFDQUHVXOWLQVHULRXVLQMXU\
7KHSUHVVXUHUHJXODWRUDQGWKHEXUQHURUL¿FHVDUHVHWIRU
natural gas. To use propane gas, the regulator and burner
RUL¿FHVPXVWEHFRQYHUWHG
7KHSURSDQHRUL¿FHVIRUWKHFRRNWRSEXUQHUVDUHVKLSSHGRQ
the back of the range in the location shown.
',QVWDOOWKHSURSDQHRUL¿FHVLQWKHLUSUHFLVHORFDWLRQV
7RSUHYHQWOHDNDJHPDNHVXUHWKHRUL¿FHVSXGVDUHVHFXUHO\
screwed into the gas supply tubes.
(,QVWDOOWKHROGRUL¿FHVSXGVLQWRWKHPHWDOER[RUEUDFNHW
along with these instructions, and replace onto the back of the
UDQJHIRUSRVVLEOHIXWXUHFRQYHUVLRQ
3URSDQH&RQYHUVLRQ.LW
PROPANE CONVERSION INSTRUCTIONS
31-2000755 Rev. 1 04-21 GEA
P2B935
95
III
Denotes 0.95mm Orifice size opening
Denotes LP (Propane)
CHECK SURFACE BURNERS
Push and turn a knob to the LITE position. A clicking sound
indicates proper operation of the ignition system. When lighting
DQ\EXUQHUVSDUNVZLOODSSHDUDWDOOEXUQHUVEXWJDVÀRZV
from only the one selected. Once air is purged from the supply
line, burner should light within 4 seconds. After burner lights,
rotate the knob out of the LITE position. Try each burner in
VXFFHVVLRQXQWLODOOEXUQHUVKDYHEHHQFKHFNHG
Quality of Flames
'HWHUPLQHWKHTXDOLW\RIÀDPHVYLVXDOO\1RUPDOEXUQHUÀDPHV
should look like (A) or (B).
/RQJEULJKW\HOORZÀDPHVDUHQRWQRUPDO1RUPDOÀDPHVPD\
show signs of an orange tint when well heated or signs of
ÀLFNHULQJRUDQJHGXHWRSDUWLFOHVLQWKHJDVRUDLU
WARNING
Explosion Hazard
Death or serious injury can result from failure to follow
these instructions.
6HUYLFHE\DTXDOLILHGVHUYLFHWHFKQLFLDQRQO\
6KXWRIIJDVVXSSO\DQGGLVFRQQHFWSRZHUEHIRUHVHUYLFLQJ
5HFRQQHFWDOOJURXQGLQJGHYLFHVDIWHUVHUYLFH
• Replace all parts and panels before operating.
$5HPRYHWKHWRSJUDWHVEXUQHUFDSVDQGEXUQHUKHDGV
%8VLQJDPPRU´QXWGULYHUUHPRYHWKHWRSEXUQHU
RUL¿FHV7KHVHPD\EHDFFHVVHGWKURXJKWKHEXUQHU
opening in the base.
NOTICE:
6DYHWKHVHRUL¿FHVIRUIXWXUHFRQYHUVLRQEDFNWRQDWXUDOJDV
&5HPRYHWKHSURSDQHRUL¿FHVIURPWKHER[SURYLGHG7KH
SURSDQHRUL¿FHVKDYHWKHOHWWHU³/´RQWKHWRS
To aid in identifying the proper location for the propane
RUL¿FHVGXULQJFRQYHUVLRQIURP1DWXUDO*DVWR3URSDQH
*DVFRORUFRGHVKDYHEHHQDGGHGWRWKHVLGHRUWRSRIWKH
RUL¿FH6HHWKHFKDUWEHORZ(DFKRUL¿FHPD\DOVRVKRZD
VHULHVRIHQJUDYHGPDUNV,,,,,,ORFDWHGRQWKHWRS
PROPANE CONVERSION INSTRUCTIONS
CONVERTING THE COOKTOP BURNERS
Multi-ring Round burner
Burner cap
Burner cap
Burner cap
Burner head
Burner head
Base
Base
2UL¿FHORFDWHG
through this
opening
LR
LF
RR
RF
Center
Propane
Red/Yellow
Propane
Orange/Light Blue
Propane
Orange/Green
Propane
None
LF2LF1
LFC
LF3
Propane
None
Propane
None
Propane
None
Propane
None