Portable Gas BBQ With Trolley Model No. G1013-NZ FOR OUTDOOR USE ONLY- OPERATES ON NZ LPG Retain these instructions for future use.
GENERAL INFORMATION Gas Installation Code This BBQ is to be used with NZ LPG only (9kg LPG cylinder) or with propane (1lb disposable propane canister). Failure to comply with these instructions could result in a fire or explosion which could cause serious bodily injury, death or property damage. Accessible parts may be very hot. Keep young children away. Any modifications of this barbecue may be dangerous. Do not move this barbecue during use. Turn off gas supply at the cylinder after use.
GENERAL INFORMATION Location of your Barbecue Read carefully before assembling and operating your barbecue. DO NOT use your barbecue in garages, porches, sheds, breezeways, or other enclosed areas. Your barbecue is to be used OUTDOORS. The barbecue is not intended to be installed in or on recreational vehicles and/or boats and should not be placed under any surface that will burn. Do not obstruct the flow of combustion and ventilation air around the barbecue housing.
22 24 01 02 23 21 M 20 19 18 03 04 05 06 07 08 09 10 17 11 12 13 14 16 15 28 25 27 26
NO. 01 02 Hood Hinge - Right Hood Figure Q'TY NO.
STEP 1 A B B B A B A M6X15 Screw 4Pcs A M6 B STEP 2 4Pcs Nut C C C B B C B B C B M6X10 Screw 4Pcs M6 Nut 4Pcs A
STEP 3 E E D D STEP 4 D M4X10 Screw 2Pcs E M4 Nut 2Pcs
STEP 5 C B M6X10 Screw C M6 B 1Pcs 1Pcs Nut STEP 6 B B B B B C B B B C C C C C C B M6X10 Screw 8Pcs 8Pcs M6 Nut C C
STEP 7 F G G F G F G F F G STEP 8 M5X35 Screw M5 Nut 4Pcs 4Pcs A A A A A M6X15 Screw 4Pcs
STEP 9 L G G L L G G L L G STEP 10 M5X10 Screw M5 Nut 4Pcs 4Pcs
STEP 11 STEP 12 C C B B C C B B C B M6X10 Screw M6 Nut 4Pcs 4Pcs
STEP 13 L L M5X10 Screw L 2Pcs STEP 14 M K K M fix the lid with "Lid Support Axle and Clip" M Clip 2PCS e l x A e g n i H K 2PCS
STEP 15 STEP 16
STEP 17 STEP 18
STEP 19 N N N M8 Nut 2
STEP 20 N N N M8 Nut 2
STEP 21
STEP 22 GENERAL ASSEMBLY
Connecting & Disconnecting to Gas Source IMPORTANT: Before connecting and disconnecting barbecue to gas source, make sure regulator is in ‘LOCK’ position. CAUTION: When the barbecue is not in use, the gas must be turned off at the cylinder. Familiarise yourself with the general information and safety guidelines located at the front of this manual. Check: 1. The cylinder is filled. A sloshing sound will be heard when shaken. 2. The regulator is in the ‘LOCK’ position. Connecting 9Kg LPG Cylinder 1.
• • • • If using the hose assembly accessory connected to a 9kg LPG cylinder, now open the gas control valve on the cylinder slowly and smoothly to ensure full gas flow. Take away the cooking ware and flame tamer, hold lit match on the burner Turn the regulator control knob anti-clockwise from LOCK to OFF position to unlock the button. Turn the regulator clockwise to MED position.
powders as they can permanently damage the finish. Rinse well and dry thoroughly. To protect the cast iron cooking surfaces; when clean and dry, apply a light coat of cooking oil to the cooking surfaces. Due to the weight of the cooking surfaces, we do not recommend cleaning in a dishwasher. It is quite normal for surface rust to be present on the cooking surface. If rust appears between uses or in storage, clean with a soft brass wire brush. Be careful not to damage the cooking surface, re-oil and cure.
PLEASE NOTE: To allow the regulator to always deliver adequate pressure of gas to the BBQ, always ensure: 1. All BBQ control knobs are in the ‘OFF’ position prior to opening the tap on the gas cylinder valve 2. When opening the cylinder valve, open the first ¼ to ½ turn slowly before opening the cylinder valve fully. For reference and correspondence record your serial number here. (see sticker on side of BBQ body) Serial No.
