MSDS

*Estimate
N/A-Not Applicable
N/R-Not Restricted
N/E-Not Established
MATERIAL SAFETY DATA SHEET
NOTE: BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
IDENTITY
(As shown on Label or package) LIQUID TAPE (F825)
PART NO.
IF APPLICABLE
SECTION I
MANUFACTURER'S
NAME Plasti Dip International Inc.
EMERGENCY PHONE No.
USA only: 1-800-424-9300 INT’L: 703-527-3887
ADDRESS (NUMBER, STREET, CITY, STATE AND ZIP CODE)
3920 Pheasant Ridge Drive
REVISION # 0003
Blaine, MN 55449
MANUFACTURER'S PHONE
No. FOR INFORMATION 1-763-785-2156
DATE MSDS
WAS PREPARED December 10, 2007
SECTION II - HAZARDOUS INGREDIENTS INFORMATION. All Health Hazards which comprise 1% or greater of the composition and all
carcinogens if 0.1% of the composition or greater.
HAZARDOUS COMPONENTS CHEMICAL and
IDENTITY AND COMMON NAME (S)
% Wt.
(OPTIONAL)
CAS NO. OSHA
PEL
ACGIH
TLV
OTHER LIMITS
RECOMMEND
VM&P Naphtha 33.5 - 35.0 64742-89-8 300 ppm 300 ppm None
Heptane 14.5 – 15.0 426260-76-6 500 ppm 400 ppm None
Xylene 12.5 – 13.0 1330-20-7 100 ppm 100 ppm None
Methyl Ethyl Ketone 7.7 - 8.3 78-93-3 200 ppm 200 ppm None
Ethylbenzene 3.0 - 3.2 100-41-4 100 ppm 100 ppm None
SECTION III - PHYSICAL / CHEMICAL CHARACTERISTICS
BOILING 175 - 285°F
POINT 79 - 141ºC
SPECIFIC GRAVITY (H
2
0 =1)
0.83
APPROXIMATE WEIGHT PER GALLON (LBS)
6.87
VAPOR PRESSURE
78 mmHg @ 20°C
VAPOR DENSITY
(AIR = 1) Heavier than air
EVAPORATION RATE
(BUTYL ACETATE =1) > 1.0
SOLUBILITY IN WATER
Insoluble
% VOLATILE 71 - 74.5%
VOC LBS./GAL 4.4 – 4.5
OTHER
(IF ANY) None
APPEARANCE
AND ODOR Various Colors, Honey Like Substance - Characteristic Odor
SECTION IV-FIRE AND EXPLOSION HAZARD DATA
FLASH POINT 20.0°F ( -7ºC)
(METHOD USED) TCC
FLAMMABLE LIMITS LEL
0.9
UEL
11.5
EXTINGUISHING
MEDIA Carbon Dioxide, Dry Chemical, or Foam
SPECIAL
FIRE FIGHTING PROCEDURES Self contained breathing apparatus with a full face piece, operated in pressure demand or other positive pressure mode.
UNUSUAL FIRE AND
EXPLOSION HAZARDS This material is flammable and may be ignited by heat, sparks, flame or static electricity.
HAZARDOUS PRODUCTS FORMED BY
FIRE OR THERMAL DECOMPOSITION Carbon Dioxide and/or Carbon Monoxide.
EXPLOSIVE LIMITS
(% BY VOLUME IN AIR) 0.9 – 11.5
SECTION V - OPTIONAL HAZARD RATINGS IDENTIFICATION
HAZARD RATING
4-EXTREME
3-HIGH
2-MODERATE
1-SLIGHT
0-INSIGNIFICANT
**SEE SECTION IV
National Fire Protection Association (NFPA)
FIRE 3 REACTIVITY 0 .
HEALTH 2 SPECIAL HAZARDS None .
This is the "front" when printed in duplex. Page 1 of 2 pages if not duplex.