SDS

Material name: UNITED COATINGS ROOF MATE HT COATING
Version #: 07 Revision date: 11-18-2015
SDS 3034
SDS US
3 / 9
Methods and materials for
containment and cleaning up
Large Spills: Stop the flow of material, if this is without risk. Dike the spilled material, where this is
possible. Cover with plastic sheet to prevent spreading. Absorb in vermiculite, dry sand or earth
and place into containers. Prevent entry into waterways, sewer, basements or confined areas.
Following product recovery, flush area with water.
Small Spills: Wipe up with absorbent material (e.g. cloth, fleece). Clean surface thoroughly to
remove residual contamination.
Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS.
Environmental precautions
Avoid release to the environment. Prevent further leakage or spillage if safe to do so. Avoid
discharge into drains, water courses or onto the ground. Inform appropriate managerial or
supervisory personnel of all environmental releases.
7. Handling and storage
Precautions for safe handling
Obtain special instructions before use. Do not handle until all safety precautions have been read
and understood. Avoid prolonged exposure. Should be handled in closed systems, if possible.
Provide adequate ventilation. Wear appropriate personal protective equipment. Avoid release to
the environment. Observe good industrial hygiene practices.
Conditions for safe storage,
including any incompatibilities
Store locked up. Store in original tightly closed container. Store away from incompatible materials
(see Section 10 of the SDS).
8. Exposure controls/personal protection
Occupational exposure limits
US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR 1910.1000)
Components Type Value
Form
Ammonium Hydroxide
20-30% (CAS 1336-21-6)
Calcium Carbonate (CAS
1317-65-3)
Paraffinic Oil (CAS
64742-65-0)
TITANIUM DIOXIDE (CAS
13463-67-7)
Zinc Oxide (CAS
1314-13-2)
US. ACGIH Threshold Limit Values
PEL 35 mg/m3
50 ppm
PEL 5 mg/m3 Respirable fraction.
15 mg/m3 Total dust.
PEL 5 mg/m3 Mist.
2000 mg/m3
500 ppm
PEL 15 mg/m3 Total dust.
PEL 5 mg/m3 Respirable fraction.
5 mg/m3 Fume.
15 mg/m3 Total dust.
Components Type Value
Form
Aluminum Trihydroxide
(CAS 21645-51-2)
Ammonium Hydroxide
20-30% (CAS 1336-21-6)
Paraffinic Oil (CAS
64742-65-0)
PARAFFINIC PETROLEUM
OIL (CAS 64742-54-7)
TITANIUM DIOXIDE (CAS
13463-67-7)
Zinc Oxide (CAS
1314-13-2)
TWA 1 mg/m3 Respirable fraction.
STEL 35 ppm
TWA 25 ppm
TWA 5 mg/m3 Inhalable fraction.
TWA 5 mg/m3 Inhalable fraction.
TWA 10 mg/m3
STEL 10 mg/m3 Respirable fraction.
TWA 2 mg/m3 Respirable fraction.
US. NIOSH: Pocket Guide to Chemical Hazards
Components Type Value
Form
Ammonium Hydroxide
20-30% (CAS 1336-21-6)
STEL 27 mg/m3
35 ppm