Instruction Manual

ManualsBrandsFujian Edgelion Power Technology ManualsElectronicsLI-ION BATTERY PACK

- 1 -

电动冲浪板用铁锂电池组 HM1501 使用说明书

Instruction manual of iron lithium battery pack HM1501

for electric surfboard

1. 产品规格与结构

1. Product specification and structure

1.1 产品规格

1.1 Product specification

型号：HM1501

Model：HM1501

规格：15S1P 48V 40Ah 磷酸铁锂电池组

Specification：15S1P 48V 40Ah Lithium iron phosphate battery pack

1.2 产品结构

1.2 Product structure

电池组外形图（15S1P）

Outline drawing of battery pack（15S1P）

2 产品性能指标

2 Product performance index

2.1 产品技术参数

2.1 Product technical parameters

项目

Item

基本信息

Basic information

备注

Remarks

电芯型号

Cell model

LP27148134

Nominal 40Ah (Cmin/0.2C)

组合方式

Combination pattern

串

并

15cells in series connection and

1 cells in parallel connection

颗电芯

15 cells

尺寸

Dimension

632*223.5*164.2

重量

Weight

23kg

Summary of content (6 pages)

PAGE 1
电动冲浪板用铁锂电池组 HM1501 使用说明书 Instruction manual of iron lithium battery pack HM1501 for electric surfboard 1. 产品规格与结构 1. Product specification and structure 1.1 产品规格 1.1 Product specification 型号：HM1501 Model：HM1501 规格：15S1P 48V 40Ah 磷酸铁锂电池组 Specification：15S1P 48V 40Ah Lithium iron phosphate battery pack 1.2 产品结构 1.2 Product structure 电池组外形图（15S1P） Outline drawing of battery pack（15S1P） 2 产品性能指标 2 Product performance index 2.1 产品技术参数 2.
PAGE 2
防水等级 Waterproof grade IP68 额定电压 Rated voltage 48V 放电截止电压 Discharging 37.5V 标称容量 Nominal capacity 40Ah 标准循环寿命 Standard cycle life ≥2000 次标准充放电循环 2000 次，放电容量 ≥80%初始容量。剩余容量≥90% 该容量是指标准充电后，在 23°C±2° 环境下贮存 28 天，以 No.3 的条件下所测得的容量。初始交流内阻 Initial AC internal resistance ≤15mΩ 标准充电后，在 AC 1KHz 条件下测量的交流阻抗(该处所标内阻为电池包内阻，单体芯内阻为 ≤0.
PAGE 3
. 产品使用方法 3. Product usage 3.1 电池充电 3.1 battery charging 3.1.1 电池使用后，应对其进行及时充电。本电池必须使用配套的专用充电器对电池进行充电。 3.1.1 After the battery is used, it shall be charged in time. The battery must be charged with a matching special charger. 3.1.2 充电时先将充电机先接上 220V 交流电源，待充电器自检完成进入待命状态下，将输出接口插入电池的充电接口中，充电器会自动与电池进行通讯握手，握手成功后进行充电状态对电池进行充电，充电 1~1.5 小时至充电机显示屏上显示充电完成即可使用。 3.1.2 When charging, first connect the charger with 220V AC power supply.
PAGE 4
Do not place the battery in the fire to avoid explosion. ● 切勿将电池端子短路或电池反充电； Do not short circuit the battery terminal or reverse charge the battery. ● 切勿拆开或穿刺电池外壳； Do not disassemble or puncture the battery case. ● 使用者手湿，切勿触摸电池端子，否则有电击风险； The user's hands are wet, do not touch the battery terminals, otherwise there is a risk of electric shock. ● 不要挤压、撞击电池； Do not squeeze or impact the battery.
PAGE 5
6.2 电量在 20~40%的电池存储时应该每隔 30~60 天充一次电。每次使用后，请及时为电池充电，电池内部有智慧晶片记录电池的充放电情况，若出现过度充电或充电不足导致的电池损坏不在保修范围内。 6.2 When 20-40% of the battery is stored, it should be charged every 30-60 days. After each use, please charge the battery in time. There is an intelligent chip inside the battery to record the charge and discharge of the battery. If the battery is damaged due to overcharge or insufficient charge, it is not covered by the warranty. 6.3 请勿使用非原装充电器对电池进行充电，如果使用非原装充电器对电池充电造成的电池损坏不在保修范围内。 6.
PAGE 6
Consult the dealer or an experienced radio/TV technician for help. RF warning statement: This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with minimum distance 20cm between the radiator & your body.