Car Refrigerator FCR/FC-15 FCR/FC-30 FCR/FC-40 FCR/FC-50 FC-75 FC-95 FC-100 Car Refrigerator Manual Ver : 1.0.0.
Thank you for choosing smart car refrigerator products.Please read this manual carefully before using. Keep the manual in a safe place. Please hand on this manual together if you deliver the refrigerator to another person. Contents 1. Manual Notifications 1 2. Safety Instructions 1 3. Operation 3 4. Use of refrigerators 5 5. Cleaning and Maintenance 8 6. Other Settings 9 7. Troubleshooting 9 8. Technical Data 12 9.
Manual Notifications WARNING ! • Safety instructions: Improper operation may cause fatal or serious injury, and damage to the refrigerator. • Safety instructions related to current or voltage. Failure to follow this instruction may lead to injury or damage to the refrigerator and impair the function of the product. CAUTION ! • Safety instructions: failure to observe this instruction can lead to injury.
• Do not try to open the circuit part of the product. CAUTION ! • If you are operating your refrigerator on board a boat from a mains connection of 100- 240 V～ ， you must install a residual current circuit breaker between the 100 - 240 V～ mains and the refrigerator. • Seek advice from a trained technician. CAUTION ! • Battery contains acid and corrosive substances. Careful with using. • Do not store any corrosive substances.
• The temperature display is based on the temperature at the center of the container. WARNING ! • The refrigerator can work properly when the ambient temperature is between 5°C to +45°C and the maximum humidity is 90%. • The refrigerator works properly under the maximum inclination angle 30 degrees. (Note: If the inclination angle exceeds 15 degrees, the noise will increase when the refrigerator is working, but no influence to the refrigeration function).
2 Power-on operation Warning--danger of damaging the refrigerator • The refrigerator can be directly plugged in 12V DC power supply or 24V DC power supply. • Before connecting the power, please check whether the output voltage of the power supply meets the working voltage range of the product. Warning--electric current danger • Connect the DC power cable directly to the battery with a 10A fuse.
CAUTION ! • Disconnect the refrigerator and other power consuming devices from the battery before connecting the quick charging device. • The refrigerator consumes a certain amount of current during operation. Therefore, when the refrigerator is not used for a short period of time, please turn it off directly. 3 Battery protector • For safety reasons, the refrigerator is equipped with an electronic system to prevent polarity reversal.
1 Power On/Off • Switch on the refrigerator, press the on/off button, then the LCD display lights up and the compressor starts to work. • Long press the on/off button for 3 seconds, the buzzer will beep for 1 second, then the LCD display lights off and the compressor will stop working. 2 Setting temperature • Press the setting button, the buzzer will beep for 500ms, and the temperature display on the LCD screen will start to flash.
• Switch on, press or long press the setting button, the Bluetooth of the refrigerator starts broadcasting. • The Bluetooth icon on the LCD screen lights up, and the mobile app can be connected to Bluetooth. • After connecting, you can set the refrigerator through the app. • After turn off the mobile app, the Bluetooth connection display will be automatically cancelled. Input power 12V 12<->24V 24V Voltage gear Compressor ON/OFF voltage (V) Low on 11.4±0.3 Mid on Hi on Low off 12.2±0.3 12.6±0.3 10.
• Avoid unnecessarily low temperatures. • Do not leave the lid of the refrigerator open longer than necessary. • If you do not use the refrigerator for a long time, please keep the refrigerator as follows: • Unplug the DC power cord from the DC port or remove the power cable from the battery. • Clean the refrigerator.Keep the refrigerator lid open to against moisture and mustiness. Cleaning and Maintenance 1 Cleaning • The device can be used directly without cleaning.
• Humidity can form frost in the interior of the cooling device or on the evaporator, which will reduce the cooling capacity. • When defrosting, please do not use sharp tools or tools that may damage the refrigerator evaporation plate or plastic parts. Please defrost at an appropriate time. • To defrost the refrigerator, proceed as follows： • Please take out the contents of the cooling device and place them in another cooling device to keep them cool. Switch off the device.
1 Temperature detection fault • When the temperature detection fails, the display shows an error message [ F1°C ], it means the NTC function is defective, which can only be repaired by an authorised repair centre. • When the fault indicator flashes, it means the DC power supply voltage is lower than the currently set "Battery Voltage Protection" gear. The battery needs to be charged or set the "Battery Voltage Protection" gear lower for using continuously.
2 Bad cooling effect and high internal temperature Fault The compressor has been working for a long time or in working condition all the time Possible Causes Ambient temperature is too high Move the device to a place with suitable ambient temperature Poor ventilation or insufficient air supply Move the device to another place to ensure a good ventilation environment Condenser is dirty Fan failure The compressor works intermittently 3 Suggested Remedy The battery is exhausted Clean the condenser
Technical Data Model Dimensions Capacity FC-15 FC-30 FC-40 632*360*303 635*392*446 635*392*526 mm mm mm 15L 30L FC-50 635*396*606 mm 40L 50L Cooling System Low-noise/high-performance compressor, pasted tube evaporation plate Temperature Range -22°C ~ +10°C N.W. (kg) 11kg 19kg 20.5kg 22.5kg Stable working current DC12V/24V 6.5A 3.0A 7.0A 3.2A 7.5A 3.4A 7.8A 3.
Model Dimensions Capacity FCR-15 FCR-30 FCR-40 632*360*303 635*396*446 635*392*526 mm mm mm 15L 30L FCR-50 635*396*606 mm 40L 50L Cooling system Low-noise/high-performance compressor, pasted tube evaporation plate Temperature range -22°C to +10°C N.W. (kg) 12.1kg 20.1kg 21.6kg 23.6kg Stable working current DC12V/24V 6.5A 3.0A 7.0A 3.2A 7.5A 3.4A 7.8A 3.
Product Safety Certification • Certification: CCC, CB, GS, CE, RoHS, EMC, SAA, FCC, etc. • The company reserves the rights to choose versions, technical modifications and delivery options. • This refrigerator is a non-fluorine refrigerator, and the refrigerant is R134a.
Harmful Substance Parts Name Lead Mercury （Pb） （Hg） Hexavalent Cadmium Polybrominated chromium （Cd） biphenyls（PBB） （Cr(VI)） Polybrominated Diphenyl Ether （PBDE） Body and its components O O O O O O Door body and its components O O O O O O Insulation Materials O O O O O O Compressor O O O O O O Compressor controller X O O O O O Refrigeration components O O O O O O Refrigerant O O O O O O Electrical components O O O O O O Power cord and connection lin
