Installation & Operation Manual (ZoneAire Series 2016 - 2020) (2016, 2017, 2018, 2019, 2020)
Table Of Contents
- Table of Contents
- Congratulations
- General Instructions
- WARNING
- Refrigeration system under high pressure
- WARNING
- Read Installation Operation Manual
- Your safety and the safety of others are very impo
- General Specifications
- Typical Unit Components and Dimensions
- Installation Checklist
- PTAC Installation Recommendations
- For proper PTAC unit performance and maximum opera
- For PTACs on the ground floor or anytime obstructi
- Wall Sleeve Installation Instructions (PDXWSA)
- WARNING
- Falling Object Hazard
- Alternate Wall Instalations
- One-Piece Deep Wall Sleeve Installation (PDXWSEXT
- PXDR10 Drain Kit Installation Instructions (option
- Internal Drain
- FRONT VIEW
- Drain Tube Installation (See Figure 12)
- Cover Plate Installation
- DETAIL B
- PXGA Standard Grille Insta lation Instructions
- WARNING
- Falling Object Hazard
- Electrical Rating Tables
- All units are equipped with standard power cords.
- Electrical Shock Hazard
- Power Cord Information (230/208V models only)
- Electrical Wiring for 265 Volt Models
- Power Cord Installation
- To install the line voltage power leads and condu
- Electrical Shock Hazard
- Chassis Install Preparation
- Check to be sure the wall sleeve, extension (if us
- Suffocation Hazards
- CAUTION
- Unit Damage Hazard
- Chassis Installation
- Excessive Weight Hazard
- System Configuration
- Fresh Air Vent Control
- Adjusting Air
- Backside of Front Panel
- Adjusting Louvers
- Digital Control User Input Configuration
- Dip Switch Setting
- Dip Switches
- Digital Control Operation
- Digital Control Panel
- °F vs °C Display
- Cooling Mode
- Heating Mode
- Heat Pump Models (PZH)
- Heat/Cool Models (PZE)
- Emergency Heat Operation
- Constand Fan
- Setting Temperature Limit
- Remote Control Thermostat Installation
- Install Thermostat
- The Thermostat should NOT be mounted:
- To control the unit with a wall mounted thermosta
- Thermostat Connections
- Control board with optional PDXRTB escutcheon kit
- Front Desk Control Terminal
- Energy Management
- Final Inspection & Start-up Checklist
- WARNING
- Decorative Front
- Fan Motor & Compressor
- Wall Sleeve
- Basic Troubleshooting
- Accessories
- PZ-SERIES
2
Table of Contents
Congratulations
·····················································································································································
3
General Instructions
···············································································································································
3
General Specifications············································································································································ 4
Installation Checklist···············································································································································4
PTAC Installation Recommendations························································································································· 5
Wall Sleeve Installation Instructions (PDXWSA)··········································································································· 6
Alternate Wall Instalations
·······································································································································
7
One-Piece Deep Wall Sleeve Installation (PDXWSEXT)
································································································
9
PXDR10 Drain Kit Installation Instructions (optional for new construction)········································································10
PXGA Standard Grille Insta lation Instructions··········································································································· 12
Chassis Install Preparation····································································································································16
Chassis Installation·············································································································································· 18
Friedrich PTAC Digital Control and Unit Features
·······································································································
19
System Configuration
···········································································································································
21
Digital Control User Input Configuration···················································································································· 22
Digital Control Operation······································································································································· 23
Remote Control Thermostat Installation···················································································································· 24
Remote Thermostat and Low Voltage Control Connections Remote Thermostat······························································· 24
Final Inspection & Start-up Checklist
························································································································
26
Basic Troubleshooting
··········································································································································
27
Accessories························································································································································ 29
NOTE:
All PTAC 7K,9K,12K units come with a standard 3.6KW electric heater (20A power cord).All PTAC 15K units
come with a standard 5KW electric heater(30A power cord) .