Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
13 PB
SPECIFICATIONS
General Specications 12-15k Heat Pump
PTAC Heat Pump models
PDH12K PDH12R PDH15K PDH15R
PERFORMANCE DATA:
Cooling Btu 11800/11600 11800 14500/14200 14500
Cooling Watts 1015/1000 1015 1390/1365 1390
Energy Efcient Ratio, Eer 11.6/11.6 11.6 10.4/10.4 10.4
Reverse Heating Btu 10600/10400 10600 13300/13000 13300
Heating Watts 910/895 910 1255/1225 1255
Cop 3.4/3.4 3.4 3.1/3.1 3.1
Moisture Removal (Pints/Hr.) 2.7 2.7 3.1 3.1
Sensible Heat Ratio 0.75 0.75 0.67 0.67
ELECTRICAL DATA:
Voltage(1 PHASE, 60 Hz) 230/208 265 230/208 265
Volt Range 253-187 292-239 253-187 292-239
Current (Amps) 4.9/5.1 4.2 6.2/6.7 5.4
Reverse Heat. Amps 4.2/4.7 3.7 6.2/6.7 5.0
Power Factor 0.97 0.97 0.97 0.97
Compressor LRA 21.5 19.0 28.9 21.6
Compressor RLA 4.7 3.9 5.9 5.05
Outdoor Fan Motor, HP 0.086 0.086 0.086 0.086
AIRFLOW DATA:
Indoor CFM, HIGH 400/390 400 400/390 400
Indoor CFM, LOW 325/310 325 325/310 325
VENT CFM 75 75 75 75
PHYSICAL DATA
Sleeve Dimensions (H x W x D) 16” x 42” x 13 3/4” (all models)
Dimensions with Front (H x W x D) 16”x 42”x 21 1/2” (all models)
Cut Out Dimensions (H x W x D) 16 1/4”x 42 1/4” (all models)
Net Weight (lbs.) 122 119 124 122
Shipping Weight (lbs.) 141 139 144 144
R-410A CHARGE (oz.) 36 36 39 39
Dimensions with Packaging (inches) 17 7/8" x 45" x 25 1/4" (all models)
Figure 204 (General Specs)