Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
121 PB
PARTS CATALOG
PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
Figure 902
ITEM PART
NUMBER
PART DESCRIPTION USED ON MODEL QTY
54 69700403 Air Inlet Door PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
55 69700410 One Way Valve PDH07K3SG, PDH07R3SG, PDH12K3SG, PDH12R3SG,
PDH15K5SG, PDH15R5SG
1
56 69700418 Capillary Sub-assy PDH07K3SG 1
56 69700424 Capillary Sub-assy PDH09K3SG 1
56 69700421 Capillary Sub-assy PDH07R3SG, PDH09R3SG 1
57 68700456 Magnet Coil PDH07K3SG, PDH09K3SG, PDH12K3SG, PDH15K5SG 1
57 68700092 Magnet Coil PDH07R3SG, PDH09R3SG, PDH12R3SG, PDH15R5SG 1
59 69700397 Compressor Gasket PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG
3
59 69700161 Compressor Gasket PDH15R5SG 3
60 69700389 Compressor and Fittings PDH07K3SG 1
60 69700393 Compressor and Fittings PDH09K3SG 1
60 69700391 Compressor and Fittings PDH07R3SG 1
60 69700395 Compressor and Fittings PDH09R3SG 1
60 69700390 Compressor and Fittings PDH12K3SG 1
60 69700394 Compressor and Fittings PDH15K5SG 1
60 69700392 Compressor and Fittings PDH12R3SG 1
60 69700396 Compressor and Fittings PDH15R5SG 1
61 69700427 Drainage Valve PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
62 69700428 Chassis Sub-assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG
1
62 69700429 Chassis Sub-assy PDH15R5SG 1
63 69700430 Foam (Water Tray) PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
64 69700433 Electric Box Assy PDH07K3SG 1
64 69700438 Electric Box Assy PDH09K3SG 1
64 69700436 Electric Box Assy PDH07R3SG 1
64 69700440 Electric Box Assy PDH09R3SG 1
64 69700221 Electric Box Assy PDH12K3SG, PDH15K5SG 1
64 69700222 Electric Box Assy PDH12R3SG, PDH15R5SG 1
65 68700120 Junction box PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
66 68700117 Junction lid PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
67 69700441 Relay PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
68 69700445 Capacitor CBB65 PDH07K3SG, PDH07R3SG 1