Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
120 PB
PARTS CATALOG
PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
Figure 902
ITEM PART
NUMBER
PART DESCRIPTION USED ON MODEL QTY
40 69700351 Temp Sensor Sleeving PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
41 69700367 Temperature Sensor PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
42 69700373 Air Flue Assy PDH07K3SG 1
42 69700375 Air Flue Assy PDH07R3SG 1
42 69700377 Air Flue Assy PDH09K3SG 1
42 69700379 Air Flue Assy PDH09R3SG 1
42 69700374 Air Flue Assy PDH12K3SG, PDH15K5SG 1
42 69700376 Air Flue Assy PDH12R3SG, PDH15R5SG 1
43 68700126 Heater Wiring Block Board PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
44 69700380 Cross Flow Fan PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
45 68700123 Motor Support Sub-Assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
46 69700381 Retaining Plate of Condenser PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
47 69700382 Fan Motor (Indoor) PDH07K3SG 1
47 69700384 Fan Motor (Indoor) PDH07R3SG 1
47 69700386 Fan Motor (Indoor) PDH09K3SG 1
47 69700387 Fan Motor (Indoor) PDH09R3SG 1
47 69700383 Fan Motor (Indoor) PDH12K3SG , PDH15K5SG 1
47 69700385 Fan Motor (Indoor) PDH12R3SG , PDH15R5SG 1
48 69700388 Clapboard PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
49 68700094 4-Way Valve PDH07K3SG, PDH09K3SG, PDH07R3SG, PDH09R3SG 1
49 68700095 4-Way Valve PDH12K3SG, PDH15K5SG, PDH12R3SG, PDH15R5SG 1
50 69700398 4-Way Valve Assy PDH07R3SG, PDH07K3SG 1
50 69700399 4-Way Valve Assy PDH09R3SG, PDH07K3SG 1
50 69700212 4-Way Valve Assy PDH12K3SG 1
50 69700214 4-Way Valve Assy PDH15K5SG 1
50 69700213 4-Way Valve Assy PDH12R3SG 1
50 69700215 4-Way Valve Assy PDH15R5SG 1
51 69700400 Outer Support Sub-assy(Right) PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
52 69700401 Cable Cross Plate PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
53 69700402 Filter Sub-Assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1