Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
119 PB
PARTS CATALOG
PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
Figure 902
ITEM PART
NUMBER
PART DESCRIPTION USED ON MODEL QTY
19 69700367 Temperature Sensor PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
20 68700192 Air Duct Sub-assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
21 68700147 Bearing Holder Sub-assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
22 68700146 Bearing Holder PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
23 68700193 Electric Heater PDH07K3SG, PDH09K3SG, PDH12K3SG, PDH15K5SG 1
23 68700194 Electric Heater PDH07R3SG, PDH09R3SG, PDH12R3SG, PDH15R5SG 1
24 68700197 Evaporator Assy PDH07R3SG, PDH07R3SG 1
24 68700458 Evaporator Assy PDH09K3SG, PDH09R3SG 1
24 68700196 Evaporator Assy PDH12K3SG, PDH15K5SG 1
24 68700196 Evaporator Assy PDH12R3SG, PDH15R5SG 1
25 68700152 Ambient Temperature Sensor PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
26 68700143 Air Outlet PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
27 68700142 Front Panel PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
28 68700128 Front Panel Clip PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
2
29 69700402 Filter Sub-Assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
30 68700199 LCD Cover Sub-assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
31 68700200 Membrane PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
32 68700201 Display Board PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
33 68700140 Filter PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
34 68700145 Remote Control Cover PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
35 68700202 Front Panel Assy PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
36 68700205 Supporting Board PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
37 68700207 Logic Main Board 1 PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
38 68700203 Supporting Board PDH07K3SG, PDH07R3SG, PDH09K3SG, PDH09R3SG,
PDH12K3SG, PDH12R3SG , PDH15K5SG, PDH15R5SG
1
39 68700206 Relay Main Board 2 PDH07K3SG, PDH09K3SG, PDH12K3SG, PDH15K5SG 1
39 68700208 Relay Main Board 2 PDH07R3SG, PDH09R3SG, PDH12R3SG, PDH15R5SG 1