Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
114 PB
PARTS CATALOG
PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
ITEM PART
NUMBER
PART DESCRIPTION USED ON MODEL QTY
41 69700367 Temperature Sensor PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
42 69700373 Air Flue Assy PDE07K3SG 1
42 69700377 Air Flue Assy PDE09K3SG 1
42 69700377 Air Flue Assy PDE12K3SG, PDE15K3SG 1
42 69700375 Air Flue Assy PDE07R3SG, PDE09R3SG, PDE12R3SG, PDE15R5SG 1
43 68700126 Heater Wiring Block Board PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
44 69700380 Cross Flow Fan PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
45 68700123 Motor Support Sub-Assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
46 69700381 Retaining Plate of Condenser PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
47 69700382 Fan Motor (Indoor) PDE07K3SG 1
47 69700386 Fan Motor (Indoor) PDE09K3SG 1
47 69700384 Fan Motor (Indoor) PDE07R3SG 1
47 69700387 Fan Motor (Indoor) PDE09R3SG 1
47 69700383 Fan Motor (Indoor) PDE12K3SG, PDE15K5SG 1
47 69700385 Fan Motor (Indoor) PDE12R3SG, PDE15R5SG 1
48 69700388 Clapboard PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
49 69700389 Compressor and Fittings PDE07K3SG 1
49 69700393 Compressor and Fittings PDE09K3SG 1
49 69700391 Compressor and Fittings PDE07R3SG 1
49 69700395 Compressor and Fittings PDE09R3SG 1
49 69700390 Compressor and Fittings PDE12K3SG 1
49 69700394 Compressor and Fittings PDE15K5SG 1
49 69700392 Compressor and Fittings PDE12R3SG 1
49 69700396 Compressor and Fittings PDE15R5SG 1
50 69700397 Compressor Gasket PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG
3
50 69700161 Compressor Gasket PDE15R5SG 3
51 69700400 Outer Support Sub-assy(Right) PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
52 69700401 Cable Cross Plate PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
53 69700402 Filter Sub-Assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
54 69700403 Air Inlet Door PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
55 69700404 Inhalation Tube PDE07K3SG, PDE07R3SG 1
Figure 901