Service and Parts Manual (2016, 2017, 2018, 2019, 2020, 2021, 2022)
Table Of Contents
- INTRODUCTION
- Important Safety Information
- Personal Injury Or Death Hazards
- Operation of Equipment in During Construction
- Model Number Reference Guide
- Serial Number Reference Guide
- General Specifications 7-9k Electric Heat
- General Specifications 7-9k Heat Pump Models
- General Specifications 12-15k Electric Heat
- General Specifications 12-15k Heat Pump
- Electrical Data
- Function and Control
- Dip Switch Function #1
- Dip Switch Function #2
- Dip Switch Function #3&4
- Dip Switch Function #5&6
- Dip Switch Function #7
- Refrigeration Sequence Of Operation
- Refrigerant System Diagram
- Remove The Chassis
- Remove The Chassis
- Indoor Motor, Wheel, & Heating Element Assembly
- Outdoor Motor, Blade, & Shroud Assembly
- Electronic Board & Electrical Component Replacement
- PTAC Installation Recommendations
- Wall Sleeve Installation Instructions (PDXWS)
- Alternate Wall Installations
- PXDR10 Drain Kit Installation
- External Drain
- PXGA Standard Grille
- Electrical Wiring for 265 Volt Models
- Chassis Install Preparation
- Chassis Installation
- How To Connect
- Thermostat
- Final Inspection & Start-up Checklist
- Refrigerant Charging
- Undercharged Refrigerant Systems
- Overcharged Refrigerant Systems
- Restricted Refrigerant System
- Sealed System Method of Charging/ Repairs
- Hermetic Components Check
- Reversing Valve Description And Operation
- Testing The Reversing Valve Solenoid Coil
- Checking The Reversing Valve
- Touch Test Chart : To Service Reversing Valves
- Compressor Checks
- Compressor Replacement -Special Procedure in Case of Compressor Burnout
- PCB Printed Diagram Board 1
- PCB Printed Diagram Board 2
- Testing Component Voltage at Electronic Control Board
- Testing Line Voltage
- Basic Troubleshooting
- Error Codes
- Malfunction of Temperature Sensor
- Maintenance Method for Normal Malfunction
- PDE07
- PDH07
- PDE09, PDE12, PDE15
- PDH09, PDH12, PDH15
- PARTS CATALOG
- PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
- PDH07K, PDH07R, PDH09K, PDH09R, PDH12K, PDH12R, PDH15K, PDH15R
- Reference Sheet of Celsius and Fahrenheit
- Resistance Table of Indoor Ambient Temperature Sensor (15K)
- Resistance Table of Tube Temperature Sensors for Indoor and Outdoor(20K)
- Resistance Table of Discharge Temperature Sensor for Outdoor(50K)
112 PB
ITEM PART
NUMBER
PART DESCRIPTION USED ON MODEL QTY
1 69700351 Temp Sensor Sleeving PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
2 69700367 Temperature Sensor PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
3 68700179 Condenser Assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG 1
3 68700180 Condenser Assy PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG 1
4 68700135 Axial Flow Fan PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
5 68700173 Fan Motor (Outdoor) PDE07K3SG, PDE09K3SG 1
5 68700183 Fan Motor (Outdoor) PDE07R3SG, PDE09R3SG 1
5 68700182 Fan Motor (Outdoor) PDE12K3SG, PDE15K5SG 1
5 68700184 Fan Motor (Outdoor) PDE12R3SG, PDE15R5SG 1
6 68700174 Connection Board PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
2
7 68700175 Diversion Circle PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
8 68700176 Flow Guide Loop PDE07K3SG, PDE09K3SG 1
8 68700185 Flow Guide Loop PDE07R3SG, PDE09R3SG 1
8 68700187 Flow Guide Loop PDE12KI3SG, PDE15K5SG 1
8 68700186 Flow Guide Loop PDE12R3SG, PDE15R5SG 1
9 68700177 Top Cover Sub-Assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
10 68700178 Clapboard Sub-Assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
11 69700371 Cable Clamp PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
2
12 69700370 Door Thread PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
13 69700368 Hand Lever PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
14 69700369 Hand Lever PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
15 68700188 Outer Support Sub-assy(Left) PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
16 68700189 Bafe Plate PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
17 68700190 Helicoid Tongue PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
18 68700122 Rear Grill PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
19 69700367 Temperature Sensor PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
20 68700192 Air Duct Sub-assy PDE07K3SG, PDE07R3SG, PDE09K3SG, PDE09R3SG,
PDE12K3SG, PDE12R3SG, PDE15K5SG, PDE15R5SG
1
PARTS CATALOG
PDE07K, PDE07R, PDE09K, PDE09R, PDE12K, PDE12R, PDE15K, PDE15R
Figure 901