Installation Owner manual

7 Page 7 - 28 TANK SENTINEL
®
INSTALLATION GUIDE
Some AC input modules are dual-purpose and can be used as DC input
modules. These dual-purpose modules are marked with an asterisk
*
in TABLE
7-5.
• Match I/O module to the power source Voltage Type (AC or DC)
• Match I/O module to the Power Source voltage level (never exceed 250 volts)
• Match I/O output modules to the current draw of the load (never exceed 1 amp
maximum – no matter what is printed on I/O module)
Figure 7-13c. TS-IEM Internal Expansion Module – Component Location
Tips
( T2 )
TS-IEM PC BOARD: SHOWN WITH 4 INPUT,
AND 4 OUTPUT MODULES
TS-IEM PC BOARD
J1
IN / O U T 6
MT
IN / O U T 8
IN / O U T 7
170- 1058
AC ACAC
+DC- +DC-
RL6
+DC-
RL7
RL8
IN / O U T 1
IN / O U T 3
IN / O U T 4
IN / O U T 5
IN / O U T 2
MT
AC
+DC-
AC AC ACAC
RL2
RL5
+DC-+DC- +DC-+DC-
RL4
RL3
J2
RL1
F4A
+DC- +DC- + DC-
IN / O U T 6
AC AC
MT MT
IN / O U T 8
IN / O U T 7
AC
170- 1058
J1
RL6
F4A
x
W
S
FUSE
250V
RL8
FUSE
F4A
x
W
S
RL7
250V
F4A
x
W
S
250V
FUSE
250V
+DC- +DC-+DC-+ DC-+ DC-
AC
IN / O U T 1
IN / O U T 5
IN / O U T 4
IN / O U T 3
IN / O U T 2
ACACACAC
MT
MT
RL2
RL3
RL4
RL5
FUSE
x
W
S
J2
RL1
INPUT _ _ _V_ _
OUTPUT _ _ _V_ _ _A
OUTPUT MODULE:
HAS FUSE AND 4 PINS
MATCH MODULE VOLTAGE LEVEL
TYPE(AC or DC) AND CURRENT
TO POWER SOURCE.
# 4-40 HOLD-DOWN SCREW (TYPICAL)
RED L.E.D. - ON WHEN MODULE
TURNS ON / VOLTAGE IS APPLIED.
INPUT MODULE: HAS 5 PINS
MATCH MODULE INPUT VOLTAGE
WITH POWER SOURCE VOLTAGE.
RED L.E.D. -- ON WHEN MODULE
TURNS ON.
WARNING VOLTAGE MAY BE PRESENT
AT THE INTERFACE TERMINALS
EVEN WHEN THE L.E.D. IS OFF.
WARNING: DO NOT INSTALL OR
REMOVE MODULES, FUSES, OR
WIRING WITH POWER APPLIED !
TURN THE TS-2001 POWER OFF.
LOCATE, DISCONNECT, AND
CHECK ALL EXTERNAL POWER
SOURCES FOR ABSENCE OF
VOLTAGE BEFORE WORKING ON
THESE CIRCUITS.
MT
250V
FUS E
W
MT
F4A
x
S
F
U
S
E
2
5
0
V
F
4
A
W
x
S
FUSE REPLACEMENT
INSTALL ONLY
CORRECT RATING
REPLACEMENT
FUSES
FU SE
250V
W
x
F4A
S
Two different manufacturers of I/
0 modules are possible
(replacement fuses may be
different)