Product Manual

Troubleshooting / Repair Parts 7
SYMPTOM POSSIBLE CAUSE(S) CORRECTIVE ACTION
Failure to pump Pump not property primed Make sure pump casing and suction line are full of water.
See priming instructions
Reduced capacity Air pockets or leaks in suction line Check suction piping
and/or pressure
Clogged impeller Remove and clean
Pump loses prime Air leaks in suction line Check suction piping
Excessive suction lift and operating Move pump nearer water level
too near shut-off point
Water level drops while pumping, Check water supply. Add length of pipe to suction to keep
uncovering suction piping submerged end under water
Mechanical troubles Bent shaft and/or damaged bearings Take motor to authorized motor repair shop
and noises
Suction and/or discharge piping not See that all piping is supported to relieve strain on pump assembly
properly supported and anchored
1
2
3
4
5
6
8
7
9
10
10
10
11
13
12
683 0294 FL
Key Part FP5512-08 FP5522-08 FP5532-08 FP5542-08 FP5552-08
No. Description Qty. 1/2 HP 3/4 HP 1 HP 1-1/2 HP 2 HP
1 Motor - 115/230V,
60 Cycle - Single Phase 1 A100CLL A100DLL A100ELL A100FLL A100GSLL
2 Capscrew - 3/8 - 16 x 1-1/4" Lg. 2 U30-75ZP U30-75ZP U30-75ZP U30-75ZP —
2 Capscrew - 3/8 - 16 x 1" Lg. 2 — — — — U30-74ZP
3 Waster Slinger 1 17351-0009 17351-0009 17351-0009 17351-0009 17351-0009
4 Seal Plate 1 C3-1042P C3-1042P C3-1042P C3-1042P C3-181
5 Gasket 1 C20-121 C20-121 C20-121 C20-121 C20-122
6 Shaft Seal 1 U109-6A U109-6A U109-6A U109-6A U109-6A
7 Impeller 1 C105-92PN C105-92PM C105-92PL C105-92PB C105-214PCA
8 Wear Ring 1 C23-27 C23-27 C23-27 C23-27 C23-19
9 Volute Assembly - With Wear Ring 1 C101-284E C101-284E C101-284E C101-284E C101-264E
10 Pipe Plug - 1/4" NPT, Hex Head 3 U78-941ZPV U78-941ZPV U78-941ZPV U78-941ZPV U78-941ZPV
11 Base - With Motor Pad 1 J204-9 J204-9 J204-9 J204-9 J104-9
12 Capscrew - 3/8 - 16 x 1-1/2" Lg. 2 U30-76ZP U30-76ZP U30-76ZP U30-76ZP —
12 Capscrew - 3/8 - 16 x 1-1/4" Lg. 2 — — — — U30-75ZP
13 Motor Pad 1 C35-5 C35-5 C35-5 C35-5 C35-5
Repair Parts List