Owner's Manual OUTDOOR FIRE PIT TABLE ITEM # 62208 ATTACH YOUR RECEIPT HERE Serial Number ___________ Purchase Date _____________ Manufacturer: Changzhou Wellife Furnace Co., Ltd. Conforms to ANSI Z21.97-2014, CSA STD 2.41-2014 Outdoor Decorative Gas Appliances Questions, problems, missing parts? Before returning to your retailer, call our customer service hotline at 1-866-985-7877, 9 a.m. – 6 p.m., EST, Monday – Friday or email at cservice@welltraveled.net.
PACKAGE CONTENTS PART DESCRIPTION QUANTITY A B C D E F G H I J K L Removable Burner Cover Burner Table Top Side Panels Door Panel Leg 1 Leg 2 Leg 3 Gas Tank Support Bar Gas Tank Support Ring Protective Fire Pit Cover Glass Beads 1 1 1 3 1 2 1 1 1 1 1 1 2
HARDWARE CONTENTS SAFETY INFORMATION SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble, operate or install this appliance. If you have any questions regarding the product, please call customer service 1-866-985-7877, 9 a.m. – 6 p.m., EST, Monday – Friday. This appliance has been tested to and complies with the ANSI Z21.97-2014, CSA 2.41-2014 Outdoor Decorative Gas Appliances.
SAFETY INFORMATION DANGER DANGER ·CARBON MONOXIDE HAZARD ·This fire pit is a combustion appliance. All combustion appliances produce carbon monoxide (CO) during the combustion process. This product is designed to produce extremely minute, non-hazardous amounts of CO if used and maintained in accordance with all warnings and instructions. Do not block air flow into or out of the fire pit.
SAFETY INFORMATION WARNING WARNING California Proposition 65 By-products of the cumbustion fuel used by this product contain chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm. ·This product is fueled by propane gas. Propane gas is invisible, odorless, and flammable. An odorant is normally added to help detect leaks and can be described as a "rotten egg” smell. The odorant can fade over time so leaking gas is not always detectable by smell alone.
ASSEMBLY NOTE: It is best to use TWO PEOPLE for assembly of this appliance. 1. Locate 4 – Legs (F/G/H). Screw 2 – Studs (O) into the holes on each side of the leg. Make sure all legs have the foot end facing down, then align holes in 3 - Side Panels (D) with ends of the Studs (O) sticking out of each leg. Attach the Side Panels to the Legs using Washer/Spring Washer/Nut (Q/R/S). Tighten loosely with Wrench (U). (DO NOT OVERTIGHTEN as you will need to adjust panels to ensure proper alignment.
ASSEMBLY 3 3. Attach the Table Top (C) to the Legs (F/G/H) so that it rests on the Side Panels/Door Panel using Stud (M) and Washer/Spring Washer//Nut (N). Tighten with Wrench (R). Place the Burner (B) into the hole in the Table Top (C). Make sure the Control Knob on the Burner is aligned with the Door Panel. Hardware Used 4 4. Pour the Glass Beads (L) around the Burner. Be careful not to obstruct pilot light housing. Place the Burner Cover (A) on the Burner when the fire pit is NOT in use.
ASSEMBLY 5. Connect the hose and regulator to the cylinder. The propane gas and cylinder are sold separately. Use a standard 20 lb. propane cylinder only. Use this fire pit only with a propane vapor withdrawal supply system. See Chapter 5 of the standard for storage and handling of liquefied petroleum gas, ANSI/NFPA 58. Your local library or fire department should have this book. Storage of an appliance indoors is permissible only if the cylinder is disconnected and removed from the appliance.
ASSEMBLY Do not store a spare LP-gas cylinder under or near this appliance; Never fill the cylinder beyond 80 percent full; Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve that is provided with the cylinder valve. Other type of caps or plugs may result in leakage of propane. ATTENTION: THIS PRODUCT IS NOT FOR COMMERCIAL USE INTENDED FOR RESIDENTIAL USE ONLY. Do not sit or stand on this table.
OPERATION INSTRUCTIONS Leak Test WARNING Perform all leak tests outdoors. Extinguish all open flames. NEVER leak test when smoking. Do not use the fire pit until all connections have been leak tested and do not leak. Hose / Regulator connection Regulator / Cylinder connection Underside of burner 1. Make 2-3 oz. of leak test solution (one part liquid dishwashing detergent and three parts water). 2. Apply several drops of solution where hose attaches to regulator. 3.
OPERATION INSTRUCTIONS DANGER WARNING • CARBON MONOXIDE HAZARD • For outdoor use only. Never use inside house, or other unventilated or enclosed areas. This fire pit consumes air (oxygen). Do not use in unventilated or enclosed areas to avoid endangering your life. Very hot while in operation! Never lean over the fire pit while in use. Failure to comply with these instructions may result in serious bodily injury.
OPERATION INSTRUCTIONS WARNING FOR YOUR SAFETY Be careful when attempting to manually ignite this fire pit. Holding in the control knob for more than 10 seconds before igniting the gas will cause a ball of flame upon ignition. When fire pit is ON: Burner will display tongues of blue and yellow flame. These flames should produce thick black smoke, which would indicate an obstruction of airflow through the burner. The flame should be blue with straight yellow tops. “Troubleshooting”on page 15.
CARE AND MAINTENANCE Gas odor with extreme yellow tipping of flame. Fire pit does NOT reach the desired temperature. Fire pit glow is excessively uneven. Fire pit makes popping noises. Spiders and insects can nest in burner or orifices. This dangerous condition can damage fire pit and render it unsafe for use. Clean burner holes by using a heavy-duty pipe cleaner. Compressed air may help clear away smaller particles. Carbon deposits may create a fire hazard.
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Propane cylinder is frosted over Wait until the propane cylinder warms up and becomes unfrosted Blockage in orifice Clear blockage Control knob is not in ON position Turn control knob to ON Gas pressure is low Turn cylinder valve OFF and fill the cylinder Outdoor temperature is less than 40ºF and tank is less than 1/4 full Use a full cylinder Control knob fully ON Check burner and orifices for blockage Carbon build-up Dirt or film on
Distributed By: Well Traveled Living 716 S 8th Street Amelia Island, FL 32034 Toll Free: 866-WTL-SUPP (866-985-7877) Web: www wtliving com Email: cservice@welltraveled.net 5 YEAR LIMITED WARRANTY – Customers in the Continental US All components are warranted for a period of 5 years after date of purchase by the original owner against defects in materials and workmanship under normal use.
