Operating Guide

ManualsBrandsFire Sense ManualsHeating, Ventilation, and Air Conditioning46,000 BTU Mocha and Stainless Steel Propane Gas Commercial Patio Heater

Outdoor Patio Heater

Item#: 60368, 60485, 61185, 61444, 61726, 61727, 61728, 61729,

61730, 61735, 61736, 61737, 61738, 61739, 61740, 61741,

61742, 61743



Before returning to your retailer, our exceptional customer service is available.

Call us toll-free at (866) 985-7877 , email us

at , or go online and live chat at .



FOR YOUR SAFETY:

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open ame.

3. If odor continues, keep away from the

appliance and immediately call your gas

supplier or re department.



DANGER indicates an imminently

hazardous situation which, if not avoided,

will result in death or serious injury.



Failure to comply with the precautions

and instructions provided with this heater

can result in death, serious bodily injury

and property loss or damage from hazards

of re, explosion, burn, asphyxiation,

and/or carbon monoxide poisoning. Only

persons who can understand and follow

the instructions should use or service

this heater.



Do not store or use gasoline or other

ammable vapors and liquids in the

vicinity of this or any other appliance.

An LP-cylinder not connected for use

shall not be stored in the vicinity of this

or any other appliance.



Improper installation, adjustment,

alteration, service or maintenance can

cause property damage, injury or death.

Read the installation, operation and

maintenance instructions thoroughly

before installing or servicing this

equipment.



FOR OUTDOOR USE ONLY!





Keep a copy of your proof of

purchase or order conrmation

which will be needed if you

need to contact us about

warranty coverage.

Serial No.

Purchase Date

Comfort, Quality & Style Since 1998

Summary of content (16 pages)

PAGE 1
Comfort, Quality & Style Since 1998 Outdoor Patio Heater Item#: 60368, 60485, 61185, 61444, 61726, 61727, 61728, 61729, 61730, 61735, 61736, 61737, 61738, 61739, 61740, 61741, 61742, 61743 DANGER FOR YOUR SAFETY: If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call your gas supplier or fire department.
PAGE 2
BEFORE YOU BEGIN Table of Contents Before You Begin Page 2 Safety Information Page 3-4 Package Contents Page 5 Hardware Contents Page 6 Assembly Page 6-10 Operating Instructions Page 11-14 Care and Maintenance Page 15 Troubleshooting Page 16 Replacement Parts List Page 17 Warranty Information Page 18 BEFORE YOU BEGIN Please read and understand this entire manual before attempting to assemble, operate or install this appliance.
PAGE 3
SAFETY INFORMATION DANGER EXPLOSION—FIRE HAZARD • Keep solid combustibles, such as building materials, paper, or cardboard a safe distance away from the heater as recommended by the instructions. • Provide adequate clearances around air openings into the combustion chamber. • Never use the heater in spaces which do or may contain volatile or airborne combustibles, or products such as gasoline, solvents, paint thinner, dust particles, or unknown chemicals.
PAGE 4
PACKAGE CONTENTS B A C D PART DESCRIPTION QUANTITY A Reflector Panel 4 packed in 2 inner cartons B Reflector Center Cap 1 C Head Assembly 1 packed in 1 inner carton D Tank Housing 1 E Gas Hose 1 attached to Head Assembly F Upper Post 1 G Lower Post 1 H Regulator 1 packed with Head Assembly I Post Supports 3 packed in 1 inner carton J* Base* 1 K Wheel Assembly 1 packed with Head Assembly L Chain (secures LPG cylinder) 1 packed with post supports *Some models come wit
PAGE 5
Assembly PREPARATION Before beginning assembly of this appliance, make sure all parts are present. Compare all parts with package contents list and hardware contents as listed on page 4 of this manual. If any part is missing or damaged, do not attempt to assemble this product. Contact customer service for replacement parts.
PAGE 6
Assembly 3 Attach the Lower Post G to the Post Supports I. Once you have tightened the bolts holding the Post Supports I to the Base J, align the holes in the Lower Post G with the holes on the tops of the Post Supports and insert a Large Bolt through the hole in the Post Support. Secure with a Small Flange Nut. Repeat this in the 5 remaining holes (6 holes total—2 for each Post Support piece). Hand tighten initially then tighten with the Wrench when all bolts have been inserted.
PAGE 7
Assembly 7 Attach Head Assembly C to Upper Post F. Route Gas Hose E down into Upper/Lower Posts F/G and align 4 small holes on the Head Assembly C with 4 Small holes in the Upper Post F. [HINT: Control knob should be above decal on post.] Insert the 4 Small Bolts with Lock Washers through the aligned 4 holes and tighten securely with the wrench. Hardware Used: 4 x Small Bolt w/Lock Washer 8 Install Reflector.
PAGE 8
Assembly 9 While supporting heater, tilt the Head Assembly C and slide 3 Large Flat Washers over the Reflector Studs. Place the Reflector Assembly onto the Reflector Studs and slide 3 Large Flat Washers over the Reflector Studs and onto the Reflector Assembly. Secure with 3 Wing Nuts. Once you have tightened the Wing Nuts, return the heater to an upright position. Hardware Used: 6x Large Flat Washer | 3x Wing Nut 10 Connect the hose and regulator to the LP cylinder. The LP cylinder is sold separately.
PAGE 9
Operating Instructions A minimum supply pressure of .5 psi is required for the purpose of input adjustment of propane gas. Storage of an appliance indoors is permissible • Do not store a spare LP-gas only if the cylinder is disconnected and removed from the appliance. A cylinder cylinder under or near this must be stored outdoors in a well-ventilated area out of the reach of children. appliance.
PAGE 10
Operating Instructions Before Turning Gas Supply ON: LEAK TEST WARNING 1. Make 2-3 oz. of leak test solution (one part liquid dish washing detergent and three parts water). 2. Apply several drops of solution where hose attaches to regulator. • Perform all leak tests outdoors. • Extinguish all open flames. • NEVER leak test when smoking • Do not use heater until all connections have been leak tested and show no signs of leakage. 1. Your heater was designed and approved for OUTDOOR use only.
PAGE 11
Operating Instructions Lighting WARNING NOTE: For initial start or after any cylinder change, hold the control knob in for 2 minutes to purge air from all gas lines Turn PUSH in before proceeding. 1. Turn the control knob to the “OFF” FOR YOUR SAFETY Be careful when attempting to manually ignite this heater. Holding in the control knob for more than 10 seconds before igniting the gas will cause a ball of flame upon ignition. position. 2. Fully open the LP cylinder valve. When Heater is ON: 3.
PAGE 12
Operating Instructions Operation Checklist: For a safe and pleasurable heating experience, perform this check before each use: WARNING FOR YOUR SAFETY Heater will be hot after use. Handle with extreme care. Before Operating: m I am familiar with entire owner’s manual and understand all precautions noted. m All components are properly assembled, intact and operable. m No alterations have been made. m All gas connections are secure and do not leak. m Wind velocity is below 10 mph.
PAGE 13
Care and Maintenance To enjoy years of outstanding performance from your heater, make sure you WARNING perform the following maintenance activities on a regular basis: Keep exterior surfaces clean. 1. Use soapy water for cleaning. Never use flammable or corrosive FOR YOUR SAFETY • Do NOT touch or move heater for at least 45 minutes after use. • Reflector is hot to the touch. • Allow reflector to cool before touching. cleaning agents. 2.
PAGE 14
Troubleshooting PROBLEM Main burner will not light Low burner flame Burner unit POSSIBLE CAUSE CORRECTIVE ACTION Gas valve may be off Turn gas valve ON Fuel tank may be empty Refill LPG tank Orifice blocked Clean or replace orifice Air in supply system Purge air from lines. Open gas lines and depress control knob for 2-3 minutes.
PAGE 15
PACKAGE CONTENTS B A C D PART DESCRIPTION QUANTITY A Reflector Panel 4 packed in 2 inner cartons B Reflector Center Cap 1 C Head Assembly 1 packed in 1 inner carton D Tank Housing 1 E Gas Hose 1 attached to Head Assembly F Upper Post 1 G Lower Post 1 H Regulator 1 packed with Head Assembly I Post Supports 3 packed in 1 inner carton J* Base* 1 K Wheel Assembly 1 packed with Head Assembly L Chain (secures LPG cylinder) 1 packed with post supports *Some models come wit
PAGE 16
Comfort, Quality & Style Since 1998 1 YEAR LIMITED WARRANTY Customers in the Continental US All components are warranted for a period of 1 year after date of purchase by the original owner against defects in materials and workmanship under normal use. This warranty does NOT cover normal wear and weathering, assembly and/ or maintenance OR use in a commercial application if model is not designated as a commercial model.