Installation Instructions and Owner's Manual

3
CONTENTS
GETTING
STARTED
REV 2 - 1611101520
L-C2-435
To protect against electric shock, do not immerse cord or plugs in water or other liquid.
Unplug from the outlet when not in use and before cleaning. Allow to cool before putting on or taking off parts.
Do not operate any outdoor cooking gas appliance with a damaged cord, plug, or after the appliance malfunctions
or has been damaged in any manner. Contact the manufacturer for repair.
Do not let the cord hang over the edge of a table or touch hot surfaces.
Do not use an outdoor cooking gas appliance for purposes other than intended.
When connecting, fi rst connect plug to the outdoor cooking gas appliance then plug appliance into the outlet.
Use only a properly wired and inspected 120VAC (15 AMP minimum) Ground Fault Circuit Interrupter (GFCI)
GROUNDED 3-wire receptacle with this outdoor cooking gas appliance.
The GFCI receptacle must be a WEATHER-PROOF IN-USE COVERED RECEPTACLE.
Never remove the grounding plug or use with an adapter of 2 prongs.
Use only extension cords with a 3 prong grounding plug, rated for the power of the equipment, and approved for
outdoor use with a W-A marking.
The provisions of the National Electric Code as well as any local codes must be observed when installing
the product.
ELECTRICAL SAFETY
GETTING STARTED
ELECTRICAL SAFETY .................................................3
REPLACEMENT PARTS LIST .......................................4
MODEL SPECIFICATIONS ............................................ 7
STAND-ALONE GRILL DIMENSIONS TABLE ................7
MODEL SPECIFICATIONS TABLE ..............................8
STAND-ALONE GRILL WIRING DIAGRAM ...................8
GRILL MAINTENANCE AND SAFETY
INFORMATION .............................................................9
ELECTRICAL CONNECTIONS ....................................9
INSTALLATION REQUIREMENTS .............................10
OVERHEAD CONSTRUCTION AND EXHAUST HOOD
REQUIREMENTS
....................................................10
SIDE AND REAR WALL CLEARANCES .......................11
ENSURE PROPER COMBUSTION AIR AND
COOLING AIRFLOW
...............................................12
GAS-SUPPLY PLUMBING REQUIREMENTS ...............12
PROPANE SAFETY INFORMATION ...........................13
WARNING ............................................................. 13
INSTALLATION SAFETY GUIDELINES.......................13
OPERATING THE UNIT SAFELY AND CORRECTLY .13
SAFE USE & MAINTENANCE OF PROPANE
GAS CYLINDERS .......................................................15
INSTALLATION
INSTALLATION ..........................................................16
LOCATION PREPARATION ......................................16
WHEELS AND CASTERS ..........................................16
CONNECT THE GAS SUPPLY ...................................16
INSTALL THE FLAVOR GRIDS ..................................17
CONNECT THE POWER SUPPLY TO LINE POWER .....18
INSTALL THE SIDEBURNER SHELF (IF EQUIPPED) 19
USE, CARE, & SERVICE
IDENTIFICATION OF GRILL CONTROLS ..................20
LIGHTING (IGNITION) INSTRUCTIONS ....................21
ELECTRONIC LIGHTING ........................................21
MANUAL LIGHTING ...............................................21
SHUTTING OFF THE UNIT ...................................... 21
OPTIONAL DIGITAL THERMOMETER ......................23
OPTIONAL ROTISSERIE ............................................26
OPTIONAL INFRARED BURNER OPERATION ..........27
USING THE FOLDING SHELF ....................................28
PAPER TOWEL HOLDER ............................................28
CARE & CLEANING ...................................................29
REPLACING HALOGEN BULBS ................................30
CONVERT GAS TYPE / CHECK BURNER ORIFICES . 31
BURNER AIR SHUTTER ADJUSTMENT ....................33
CONTROL PANEL REMOVAL ....................................35
NOTES PAGE ..............................................................36
TROUBLESHOOTING ................................................. 37
WARRANTY ...............................................................38