Instruction Guide

ManualsBrandsFire Magic ManualsIce MakerFire Magic 5597

REV 0 - 1608220820

L-C2-499

WARNINGS

Do not use where the supply voltage is different from the unit's requirements.

This product is designed for indoor/outdoor use.

The appearance, design, color, and parts of the product are subject to change without notice.

The functions and speciﬁ cations stated in this manual may be changed at anytime without prior notice.

The manual has WARNING and CAUTION marks. The information is important for the safe and efﬁ cient installation

and operation of the ice maker. Two types of cases may be found during installation:

CAUTION: If the instructions are not observed, a situation that may result in minor injury and/or damage to

the product may occur.

WARNING: If the instructions are not observed, serious injury or death may result.

Thank you for purchasing the 3597 Ice Maker (drain pump is optional). The product is a built-in and free-standing

type of ice maker and is designed for use at home. The product produces transparent ice of the highest quality.

Proper installation of the ice maker is of the utmost importance. The product should be installed by a qualiﬁ ed

professional service technician.

Before installing the product, read this installation manual in full. The manual contains detailed instructions to

be observed during installation. If you have any questions about installation, contact your dealer.

Important: When designing or manufacturing the ice maker, safety matters and functions are accorded the

utmost importance. This ice maker is designed and certiﬁ ed according to the UL safety standard.

The company does not bear any responsibility or liability for products that are modiﬁ ed, installed

with parts not supplied or approved, or used incorrectly. R.H. Peterson reserves the right to change

product speciﬁ cations and design at any time without prior notice.

Important: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE.

KEEP THIS MANUAL IN A SAFE PLACE AFTER READING IT.

AUTOMATIC OUTDOOR

ICE MAKER

Model # 3597

Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746

INSTALLATION INSTRUCTIONS

AND OWNER’S MANUAL

INSTALLER: Leave these instructions with consumer.

CONSUMER: Retain for future reference.

SA32944

GETTING

STARTED

Summary of content (16 pages)

PAGE 1
GETTING STARTED AUTOMATIC OUTDOOR ICE MAKER Model # 3597 INSTALLATION INSTRUCTIONS AND OWNER’S MANUAL INSTALLER: Leave these instructions with consumer. CONSUMER: Retain for future reference. Important: READ THESE INSTRUCTIONS CAREFULLY BEFORE STARTING INSTALLATION OR USE. KEEP THIS MANUAL IN A SAFE PLACE AFTER READING IT. WARNINGS Do not use where the supply voltage is different from the unit's requirements. This product is designed for indoor/outdoor use.
PAGE 2
CONTENTS GETTING STARTED WARNINGS .................................................................................................................................................. 1 IMPORTANT INFORMATION ................................................................................................................. 3 UNPACKING ........................................................................................................................................... 3 VENTILATION ...........................
PAGE 3
IMPORTANT INFORMATION UNPACKING After removing the packing materials, check the appearance of the ice maker for possible defects or irregularity. If the product shows any irregularity in its appearance, contact the dealer to inquire about it. All the packing materials (strings, box, styrofoam, and wood, etc.) should not be left within reach of children and should be disposed of responsibly. For safety, the product should be installed and used with caution in accordance with this manual.
PAGE 4
ELECTRICAL SAFETY INFORMATION • To protect against electric shock, do not immerse cord or plugs in water or other liquid. • Unplug from the outlet when not in use and before cleaning. • CAUTION: Risk of Electric Shock - Switch in OFF postion does not de-energize the unit. • Do not operate any outdoor appliance with a damaged cord, plug, or after the appliance malfunctions or has been damaged in any manner. Contact the manufacturer for repair. • Do not let the cord touch hot surfaces.
PAGE 5
SPECIFICATIONS AND DIMENSIONS (cont.) When moving the ice maker, ensure the cut-out dimensions, electric power, and piping position requirements are met. Refer to the INSTALLATION section for complete details. This product is a gravity drain model that requires a drain tube to run from the back of the product to an appropriate drain pipe. The optional drain pump routes water to a drainage point such as a neighboring sink. Important: The ice maker should be leveled.
PAGE 6
SPECIFICATIONS AND DIMENSIONS (cont.) PLUMBING REQUIREMENTS Plan for the setup of the water supply pipes. Connect the unit to a cold water source using the supplied water inlet hose. Install a shut-off valve between the tap water pipe and the product so that the user can operate the valve. Do not install the shut-off valve at the rear of the product. Do not use a self-piercing valve. If the tap water has a high level of minerals, a pipeline filter will be required.
PAGE 7
PARTS LIST Z X Y YY Y[ Y\ YZ Y] ZW Z[ Y^ ZX ZZ ZY Z] Z^ Y_ Y` \^ Z` Z_ Z\ [W [\ [Z \[ \Z \Y \X [[ [X ] [Y \ \_ ^ YX XX X] [ \] \\ X\ \W X[ XZ ]W ]W XY X^ X_ X` REV 0 - 1608220820 [_ [^ [] XW ` _ [` YW 7 L-C2-499
PAGE 8
PARTS LIST (cont.) Item Description Code No. Qty. Replacement Part No. Item Description Code No. Qty. Replacement Part No. 1. Top cover 3171006-10 1 - 31. Hand screw 2108045-01 2 - 2. Foam top cover 3060191-00 1 - 32. Cover vessel 3170906-00 1 - 3. Hinge plug 3030182-00 1 - 33. Rubber EVA pipe 2110033-00 1 - 4. Top hinge block 3210030-00 1 - 34. Ice guide 3410090-00 1 - 5. Top cover bracket 3210025-00 1 - 35. Vessel 6040014-00 1 - 6.
PAGE 9
INSTALLATION INSTALLATION INSTALL ICE MAKER This installation method is for a gravity drain pipe setup. If the optional drain pump kit is purchased, follow the installation instructions provided with the pump. Locate drain within 2" diameter area 23" back from front of unit Water inlet hose Drain tube Shut-off valve (not included) Refer to plumbing codes when connecting the ice maker to a drain connection.
PAGE 10
INSTALLATION (cont.) DOOR REVERSAL (if applicable) The direction in which the door opens can be changed. The hinges are attached to the right-hand side of the door when the product is shipped from the factory. The ice maker is designed so that the hinges may be installed on either side. If the hinges are moved to the holes on the left-hand side, the door will open to the left.
PAGE 11
USE, CARE, & SERVICE OPERATION INITIAL OPERATION 1. Open the water supply shut-off valve connected to the ice maker. ICE 2. Open the door and turn the switch at the lower end of the product to the “ICE” position. OFF 3. Discard the first batch of ice. WA SH 4. Good-quality ice is produced 1-2 hours later. USING THE ICE MAKER Turn the switch at the lower end of the product to the “ICE” position.
PAGE 12
OPERATION (cont.) ICE REMOVAL CYCLE The compressor works during the progression of the ice removal cycle, but the pump motor and fan motor are stopped. The hot gas valve and water supply valve work. When the two valves are opened and the frozen surfaces are heated, ice drops down into the container. Then the ice removal cycle is stopped and the ice production cycle is started again by the program installed in the ice maker.
PAGE 13
SERVICE AND CLEANING (cont.) ICE-PRODUCTION SYSTEM 1. Open the door and turn off the switch at the lower end of the front. 7 2. Re-connect the power supply. 3. Take out all the ice and dispose of it or store it in an ice chest or refrigerator. 8 4. Pour 4 ounces of a washing agent (neutral detergent for dishwashing or equivalent) into the water container of the ice maker. 5. Press the switch to the “WASH” position.
PAGE 14
NOTES PAGE REV 0 - 1608220820 14 L-C2-499
PAGE 15
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTION 1. Ice maker is unplugged 1. Plug the ice maker in. 2. Breaker tripped 2. Reset breaker - if it happens again, call an authorized service center. 3. Switch turned to “OFF” 3. Turn switch to “ICE”. 4. Storage bin full, keeping ice maker off 4a. Ice on sensor tube – it is normal for ice maker to be off. Ice maker does not operate 4b. Ice maker in location below 50° (10° C) – location must be warmer for ice maker to operate. 5.
PAGE 16
WARRANTY ONE-YEAR WARRANTY - Fire Magic® electric accessories are warranted for one year from the date of purchase. A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE IS REQUIRED This warranty applies to the original purchaser for products which are installed in the United States or Canada and which are operated and maintained as intended for single family residential usage.