Manual
28
SPARE PARTS - ELECTRICAL:
Item # Part # Description Notes
C1 J101486 Contactor Controls heater in Still or pump in JetVac
CTRL1 J102795 Temp control board, LS-15E/55E Controls cycle temperature from 100°F to 392°F.
CTRL1 J102734 Temp control board, LS-15IIE/55IIE Controls cycle temperature from 100°F to 392°F.
FS1 J100914 Flowswitch, LS-55E/55IIE Rated for 1½ gallons per minute.
FS2 J100913 Flowswitch, LS-15E/15IIE Rated for ½ gallons per minute.
FUSE1 J102735 Fuse, System II Protection for controls. Type 3AG 2A.
FUSE2 J102919 Fuse, System II (600 mA) Protection for Power Supply. 250 volt 5 x 20mm
LT2 J102736 Indicator light, white, System II Cooling water indicator.
LT3 J102737 Indicator light, amber, System II Heat on indicator.
MOV1 J102738 MOV, System II For surge protection.
MTR1 J103298 Motor, JetVac pump X-proof, 3450 rpm, 56C, 208-230V/1 Ph, 60 Hz.
PB1/LT1 J100323 STOP/START switch, LS-15E/55E/JV Pull on, push off switch with green light.
PB1/LT1 J102739 STOP/START switch, LS15IIE/55IIE Pull on, push off switch with green light.
POT1 J102139 Potentiometer, System II cycle temp
For adjusting the cycle temperature, 450.
POT2 J102740 Potentiometer, System II cycle time
For adjusting the cycle time, 1 M.
PS1 J102741 Power supply, System II Power supply converts 240 VAC to 24 VDC.
RC1/RC2 J101699 RC network assembly RC network, crimp connectors.
SOL1 J100889 Solenoid valve, System II water Controls the cooling water supply to the condenser.
SOL2 J102249 Solenoid Valve, JetVac relief Vacuum relief valve. Opens when JV is off.
SSR1/SSR2 J102742 Relay, solid state, System II For heater control and JetVac control.
TC1 J101157 Thermistor Temperature sensing probe for Still (Controlled by
POT 1 - 100F to 392F ) K1 is its contact.
TC2 J101157 Thermistor
Overtemp sensing probe for still (412F) K2 is its
contact.
TIM1 J102743 Timer relay, System II cycle time 16 hour timer for cycle time
TIM2 J102744 Timer relay, System II cool-down 1-hour timer for condenser water.
Note: Heater for LS-15E/15IIE is 1650 watts. Heater for LS-55E/55IIE is 6200 watts