FM120 i2 FS - FM120I2FS 120cc linear twin 4-stroke engine

ManualsBrandsFiala ManualsHobbyFM120 i2 FS 120cc linear twin 4-stroke engine

Manual for motor FM 120 i2 - FS ( Date of publication 06/2016)!

FIALA%PROP%s.r.o,%%Vysoká%56,%%75641%LEŠNÁ%,%%Czech%Republic%,%e-mail:%valachmotors@fialaprop.cz%

www.fialaprop.com! !

! ! Page!1!

"#$%#&!'()!*(+()!,"!-./!0.!1!,2!

Safety%instructions.%

It%is%imperative%that%you%read%before%handling%and%using%the%motor%this%notice%and%study%

the%motor%manual.%If%you%not%find%answers%to%your%questions,%consult%with%a%more%

experienced%colleague,%contact%your%dealer%engine%or%contact%the%manufacturer%directly.%

Remember%that%engine,%what%you%bought%is%not%a%toy%and%is%designed%only%to%drive%the%

airplane%models%under%the%terms%of%the%instructions%for%assembly%and%use.%In%the%case%of%

our%products,%it%is%a%%big%volume%motors%and%performance,%thus%this%requirement%is%more%

important.%

Summary of content (8 pages)

PAGE 1
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) Manual for motor FM 120 i2 - FS Safety instructions. It is imperative that you read before handling and using the motor this notice and study the motor manual. If you not find answers to your questions, consult with a more experienced colleague, contact your dealer engine or contact the manufacturer directly.
PAGE 2
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) If the motor or the whole model with this motor provide another person, tell him safety instructions and operating instructions. If you do these guidelines and / or instructions lost or destroyed, you can re-download them from our website. Please take great care in securing the motor in model and check it regularly. Likewise, check the propeler mounting screw.
PAGE 3
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) 1. Motor application Motor FM 120 i2 – FS is a 4-stroke gasoline motor with volume 120 ccm and is designed for use in model aircraft. It is not designed or recommended for any other use. 2. Description of the motor It is a 4-stroke motor with OHV and 2 valves per cylinder. Microprocessor ignition for easy starting and smooth running in all modes of engine speed. 3.
PAGE 4
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) Note : ignition is equipped with a security protection function, because if it is turned on and the motor is more than a minute at rest, the ignition is switched off. In this case, it is only the ignition off and on again. For more information see the instructions on electronic ignition. 6.
PAGE 5
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) - Set a slightly increased idle speed of about 3-8% (must be tested on a specific motor) - Turn the ignition - Start the motor If a situation arises that the engine will not start, there was either a glut motor fuel, or vice versa engine is lean. Because these conditions can be difficult to detect, we recommend the following procedure: - Check the fuel system (leaks, throughput, level of fuel etc.).
PAGE 6
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) 7. Running motor Each motor is factory-tested and adjusted to the basic setting. Use a fuel with a higher ratio of oil (see section 3 of this manual), ie. 1:25. While running is not recommended long term exceed the motor speed 2500 / min while controlling the temperature of the engine. Do not keep a constant speed but motor flush with the occasional addition / slow down the gas. This mode observe about the first 30 minutes of operation.
PAGE 7
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) Setting procedure: loosen the nut, place the gauge between the rod and rocker arm and adjust gradual screwing clearance so that the gauge was sliding grip. Then tighten the nut again. After tightening recheck valve clearance. More tells you the following three photos. A system of adjustment is a classic - cut right valve adjusts the left and vice versa. 9.2.
PAGE 8
Manual for motor FM 120 i2 - FS ( Date of publication 06/2016) On this photo is also seen ventilation hose crankcase. This tubing is not clogged and leave it in its original length! 11. List of common spare parts and accessories Find the www.fialaprop.com, or to inform on e-mail: valachmotors@fialaprop.cz 12. Motor repair If, during the warranty period there is a problem or failure, please contact your dealer, who will help you solve the problem, or contact the manufacturer.