Instructions / Assembly

Page | 2
INTRODUCTION
1. If the ramp’s top lip transition plates are not long enough to fully overlap a secure, unobstructed, level
landing, a SUITCASE® Top Lip Extension (‘TLE’) is an available option that increases the standard 3” reach
of the top lip transition plates to 9”, in many cases, allowing the ramp to clear an obstruction to create a
smooth transition. Visit www.ezaccess.com or call 1-800-451-1903 for more information.
Use of the TLE reduces overall ramp weight capacity to 500 lbs.; never exceed weight capacity.
If a secure, unobstructed, level landing cannot be attained, do not use the TLE or ramp.
2. The TLE must be used in pairs and is designed only for use with an appropriate EZ-ACCESS® SUITCASE®
Singlefold, Singlefold AS, TRIFOLD® AS, or OEM equivalent ramp. If you have questions concerning
compatibility, please call 1-800-451-1903. Before use, read the ramp’s instruction manual in its entirety
and follow all instructions before and during use.
SYMBOLS
The WARNING symbol indicates a potentially hazardous condition/situation. The warnings throughout this
document, and on your equipment, if any, are for the protection of people and property. Failure to abide by
warnings will result in a waiver of all liabilities, loss of your warranty, and could result in equipment damage
and or failure, property damage, risk of serious bodily injury, and or death to operators, riders, and those
nearby. The symbol may appear in various colors and in conjunction with other symbols.
The NOTE symbol indicates important information. Failure to obey all notes could result in improper operation,
less-than-optimum equipment performance, and at the sole discretion of the equipment manufacturer, may
void your warranty. The symbol may appear in various colors and in conjunction with other symbols.
WARNINGS
Maximum weight capacity is 500 lbs. (use of the TLE reduces overall ramp weight capacity to 500 lbs.); never
exceed weight capacity.
Prior to assembly and use, read and follow all instructions, warnings, and labels. Following all instructions and
obeying all warnings before and during use is necessary for safe operation. For additional information or to
obtain replacement copies of instructions or labels, call 1-800-451-1903.
For wheelchairs and scooters only; not for commercial use.
Before using the TLE with ramp, refer to your mobility equipment's owner guide for acceptable ramp usage,
including proper slope/incline, chair direction, etc.; never exceed its recommendations.
Only use the TLE with ramp with a qualified helper and always use a lap belt.
Before each use, check the TLE and ramp for worn, loose, or damaged parts. If you find any of these conditions,
do not use the TLE or ramp. Contact your dealer for service or repairs; failure to do so may cause injury.
Do not use the TLE with ramp if TLE and or ramp are damaged or unstable.
Do not tamper with, attempt to repair, or modify any portion of the TLE with ramp.
Ensure that the landing the TLE will be placed on is substantial and of sound construction.
Use only if the secure, unobstructed, level landing can support, at minimum, the same weight capacity as
the TLE (500 lbs.).
Ensure that the surface area of both TLEs fully overlaps a secure, unobstructed, level landing enough to safely
install provided clevis pins or other non-provided anchoring hardware, and rests firmly against the upper
landing. If a secure, unobstructed, level landing cannot be attained, do not use the TLE or ramp.
Ensure that the TLE with ramp is securely anchored before each use.
Use only if sufficient maneuvering room is available at both ends of the ramp with TLE to assure safe travel
when entering and exiting the ramp.
Do not use the TLE with ramp unless the carriage bolts, washers, and nylon locknuts are secure.
The TLE or ramp surfaces may become slippery in wet conditions; use caution if surfaces are wet as traction may
be reduced.
Do not use if TLE or ramp surfaces are covered with ice, snow, dirt, leaves, or other debris. Remove all
accumulations and sweep surfaces clean before use.
The TLE must be used in pairs and is designed only for use with an appropriate EZ-ACCESS® SUITCASE®
Singlefold, Singlefold AS, TRIFOLD® AS, or OEM equivalent ramp. If you have questions concerning compatibility,
please call 1-800-451-1903.
Improper use of the TLE with ramp could result in serious injury.
Always exercise caution when handling, installing, and or using the TLE.