Owners Handbook 2005 Motorhomes
Contents WELCOME & INTRODUCTION GENERAL SAFETY PREPARING FOR THE ROAD Loading SITE ARRIVAL MOTORHOME CODE CONNECTING SERVICES Water Gas Electricity SAFETY Ventilation Fire Safety SECURITY Alarm System EQUIPMENT USE Control Panels Truma Space Heater Taps CUSTOMER OBLIGATION Refrigerator Servicing Oven, Hob & Grill MOTORHOME CONSTRUCTION Smoke Alarm Main Components Thetford Cassette Toilet EQUIPMENT LISTS Air Conditioning ELECTRICAL WIRING DIAGRAMS Rooflights Windows Blinds & Flyscreens Doors Bed
Welcome & Introduction WELCOME & INTRODUCTION Thankyou for choosing an Explorer Group motorhome. Before you drive off, please familiarise yourself with the motorhome and read this owners manual. This will help you to obtain the maximum pleasure from your vehicle and avoid endangering yourself and others Additional information and detailed appliance instruction manuals are also contained in your Owner's Information Pack.
General Safety In order for you to get the most out of your new Explorer Group motorhome it is necessary for you to be aware of the following. 1. Do not obstruct ventilators. (See Safety Section - Ventilation) 2. Inspect the flexible gas hose regularly for deterioration and renew as necessary, with approved type, and in any case no later than the expiry date stated on the hose. 3.
Preparing For The Road PREPARING FOR THE ROAD Before venturing out on to the road with your motorhome, it is important that you prepare correctly. YOUR MOTORHOME (WEIGHTS EXPLAINED) MASS IN RUNNING ORDER The weight of your motorhome as it leaves the factory, as new with standard fixtures and fittings, plus an allowance for driver and 90% fuel. LOADING It should be noted that even weight distribution is a major factor in making your motorhome an easy and pleasant vehicle to drive.
UNDER NO CIRCUMSTANCES WALK ON THE OVER CAB SECTION. Roof loads should be evenly distributed and securely fastened, but care must be taken not to over-tighten straps or ropes to the point where roof rails or brackets may become distorted, particularly as during braking and cornering, forces exerted by straps or ropes are greatly increased.
Preparing For The Road MOTORWAY DRIVING Speed Limits Be sure to observe all statutory speed limits and adapt your speed to take account of prevailing weather and road conditions. 1. Reducing Speed: i) In high or cross winds. ii) Downhill. iii) In poor visibility. 2. High sided vehicles cause air buffeting so extra care must be taken when passing or being passed. As much space as possible should be given. CHANGING A WHEEL 1.
Site Arrival SITE ARRIVAL CHECK SITE REGULATIONS On arrival at a camp site, you should always check the site regulations. This will help avoid any unnecessary conflict with site management and other site users. SELECTING A PITCH Carefully select where you wish to place your motorhome. The site should be as level as possible, preferably not under or near trees, well drained and away from possible boggy areas. Consider how you will move the motorhome when it is time to leave the site.
AUTOSTRATUS AND CASTAWAY ONLY Next, wind down the corner steadies preferably onto load spreaders (blocks of wood a minimum of 15.25cm (6 inches) until they are firmly set against the ground. It is possible on very uneven sites that when fully extended blocks may be required under the corner steadies to achieve this. It is important that the motorhome is correctly levelled to ensure the correct working of the refrigerator, cooker etc.
Motorhome Code The purpose of introducing a Code of Conduct for motor caravaners is to be seen to be doing all we can as an industry to ensure that motorhomes are looked on sympathetically by legislators and other opinion formers. The main elements should cover such things as responsible camping, safe and considerate driving, parking, and other areas where a motor caravaner could cause abuse or nuisance if he or she is not careful. • Awnings and tents should only be used when permission has been obtained.
chassis manufacturer and the converter must be read and adhered to. • Care and consideration should be taken to protect the environment. • Observe the Country and Coastal Codes. Motorhome Code Explorer Group 2005 Motorhome Handbook • When ignition is on all 12V ceases except fridge. A full copy of the Motorhome Owners’ Code can be obtained from the SMMT (Society of Motor Manufacturers and Traders).
Connecting Services WATER FILLING YOUR ONBOARD WATER TANK Your onboard water tank can be filled in two ways: 1. Direct connection via a hose pipe Connect your hose pipe to a suitable water source. Unlock the water filler cap on the motorhome and insert the open end of the hose pipe. Open the tap on the water source and alow the water to flow into the tank. 2. Using a water container and pump An external submersible pump is provided with your motorhome.
GAS Your motorhome is designed to operate using either propane or butane liquefied petroleum gas at 30M/bar. Gas can be obtained from your motorhome dealer. Your motorhome is designed to accept a maximum 2 x 7.5kg gas bottles. TYPES OF GAS BUTANE Butane is supplied in the U.K. in Green or Blue bottles. All these have a male left hand thread except for Camping Gaz, which has a special female right hand, Calor 7.5 kg bottles have a special clip-on connection.
Connecting Services Each gas Appliance is connected to its own gas isolation tap. These are identified on the tap via a label. Below is a key to identify each label. To operate the tap the Arrow on the tap shows the direction of flow for the gas. The arrow should be pointing towards the appliance for the appliance to operate.
WARNING: Aerosols and highly flammable liquids must not be stored in the compartment behind, or adjacent to, any gas appliance. Some industrial LPG appliances operate at high pressure and require a ‘high pressure’ regulator. This often has an adjusting handle on it. NEVER use such a regulator on a motorhome. AWNING SPACES AND LPG APPLIANCE EXHAUST There is no danger of pollution of an enclosed awning space from the LPG exhaust from a refrigerator venting into it.
Connecting Services ELECTRICITY MAINS SUPPLY Your motorhome’s main electrical installation is designed to run on a 230v 50hz a.c. supply. 4. Remove any cover from the socket outlet provided at the site supply point, and connect the plug at the other end of the supply flexible cable to this. Switch on the main switch at the site supply point. ON ARRIVAL AT SITE 1.
IT IS IMPORTANT THAT THE MAIN SWITCH AT THE SITE SUPPLY POINT SHOULD BE SWITCHED OFF, THE SUPPLY FLEXIBLE CABLE DISCONNECTED, AND ANY COVER REPLACED ON THE SOCKET OUTLET AT THE SITE SUPPLY POINT. IT IS DANGEROUS TO LEAVE THE SUPPLY SOCKET OR SUPPLY FLEXIBLE CABLE LIVE. Connecting Services Explorer Group 2005 Motorhome Handbook PERIODICALLY 6.
Connecting Services The only certain way of equipment safe is to unplug it. making In the event of a fault the M.C.B. ‘trips’ i.e. automatically moves to the OFF position. A means of checking the polarity of the mains supply when overseas is useful. After elimination of the fault the M.C.B. can be re-set by switching to the ON position. (Against the spring pressure in an upwards direction), There are available several proprietary makes of equipment for the purpose.
The following items need to be added together if used simultaneously. 230V Mains equipment typical consumption figures: Fridge 0.50 amps Charger 0.50 amps Water heater 4.00 amps Blown air heaters 4.80 amps Colour TV 2.50 amps Microwave 10.00 amps Air conditioning 4.00 amps 12V ELECTRICAL SUPPLY N.B. The information provided in this Guide relating to fitted equipment is only intended as a quick reference.
Connecting Services CAUTION! • As with all types of transformer/power supply a certain amount of heat is generated, this will vary with the charge rate, therefore adequate space and ventilation must be provided and maintained around the unit to aid cooling. • • Keep all flammable materials and aerosols well away from this appliance and other sources of heat, as this could cause the pressure in the aerosol to rise. Should a seal then fail it is possible an explosion will ensue. N.B.
The RCD is fitted to provide protection against earth faults and possible electric shock. In the event of an earth fault which would cause a current leaking to earth, either directly or via the human body, the unit should immediately trip and switch OFF the supply. After elimination of the fault it will be possible to manually reset the RCD to the ON position by switching the switch in an upward direction against the spring pressure, and so restore the supply again.
Safety VENTILATION LOW-LEVEL VENTILATION All motorhomes manufactured by the Explorer Group Limited are ventilated at both high and low level in accordance with BSEN 721 Safety Ventilation. The fixed ventilation points fitted in your motorhome must not be blocked under any circumstances as your safety may depend upon them. It is advisable that the fixed ventilation points are checked and cleaned (where necessary) on a regular basis.
FIRE FIRE EXTINGUISHERS It is recommended that a 1 kg (2lb) minimum capacity dry powder fire extinguisher be carried inside your motorhome at all times. A fat pan fire must not have an extinguisher aimed at it, but must be smothered with a fire blanket. IN CASE OF FIRE 1. Get everyone out of the motorhome as quickly as possible using whichever exit is quickest including windows. Do not stop to collect any personal items.
Security THEFT DETERRANT, PREVENTION AND SECURITY OF YOUR MOTORHOME Security of your motorhome is taken very seriously at The Explorer Group. That is why we have provided a combination of standard features and optional extras designed to deter and prevent thieves from stealing your property. And in the unlikely event that they should succeed, aid the identification and speedy recovery of your property and assist in the prosecution of the thief.
retailers and potential buyers to check the correct ownership details. SERIAL NUMBER Record your motorhome serial number (which can be found stamped on a plate fixed beneath the motorhome door or pillar), and your cab chassis serial no. (which can be found on a plate under the bonnet). Make a note of this number in the space provided at the front of this handbook and make a separate note of the number to keep safe at home.
Security ALARM SYSTEM (if fitted) Your motorhome may have been fitted with a CONCEPT K.E.L. alarm system. This provides comprehensive protection for your motorhome, when parked. As well as protecting its contents. The alarm system is controlled by a simple key fob (your motorhome comes with two key fobs as standard), which can also switch the awning lights on and off.
PRODUCT SPECIFICATIONS Alarm Sensors Anti Theft Alarm Foot-brake operation Intruder Alarm Sensor on living quarters door Interior Alarm PIR head(s) Alarm Output Audible Alarm Siren sounds for 2 minutes producing 110dB fluctuating between 2.0KHz and 2.8KHz Security Explorer Group 2005 Motorhome Handbook ANTI TAMPER FEATURES Cutting wires to sensor on living quarters door. Cutting wires to PIR head(s).
Equipment Use CONTROL PANEL "PC-200 EX" AUTOCIRRUS/CALYPSO/AUTOSTRATUS/CASTAWAY 13 It shows the test or alarm batteries together with the symbols 10 or 11. 14 It shows the connection to the 230v net. 15 It shows that the minimal voltage device has switched on. 16 It shows the drink water test tank, the blinking means empty tank alarm. 17 The blinking means full waste water tank alarm. 18 It shows the unit of measure: U=Volt, I=internal temperature, E=external temperature.
COMPASS AVANTEGARDE ELDDIS AUTOQUEST / AVANTGARDE CONTROL PANEL The control panel consists of a gauge, three switches and two indicator lights. GAUGE The gauge will normally show the voltage in the vehicle or auxiliary battery depending on the position of the AUX/VEH change over switch. The gauge can also show the water level in the inboard water tank (see Water Switch).
Equipment Use SPACE HEATER AND WATER HEATER CONTROLS This unit contains both the controls for the Ultraheat space heater and the Ultrastore water heater. Full details on how to operate the Ultraheat space heater and the Ultrastore water heater are contained in the Truma manuals supplied within your Owner's Information Pack and under the relevant section of this handbook. PLEASE NOTE: You must ensure all replacement bulbs are of the correct rating - see Index - Equipment Lists.
must be kept clear of dirt and snow slush. GAS HEATER OPERATING INSTRUCTIONS 2. Before switching on the heater in winter, clear all snow from the cowl. Refer to manufacturer's operating instructions for winter use. AUTOQUEST / AVANTGARDE GAS HEATER - OPERATION WITH THE PIEZO IGNITOR (S 3002 P ONLY) 1. Turn on gas cylinder and open quickacting valve in the gas supply line. Equipment Use Explorer Group 2005 Motorhome Handbook 3.
Equipment Use Always wait at least 2 minutes before at tempting to re-ignite, otherwise there is a risk of blowback (misfiring). This also applies if a working heater goes out and has to be re-lit. If air has got into the gas line, it may take up to two minutes before gas is available for combustion. During this period, the operating handle should be kept pressed down and the pressure igniter constantly actuated until the flame appears. 5.
to avoid problems of this kind, otherwise satisfactory temperature control cannot be guaranteed. Gas Heater - Switching Off 4. When operating a brand new heater for the first time (or after it has been idle for a lengthy period) you may temporarily notice a slight smoke and smell. We advise running the heater at full power and thoroughly ventilating the room.
Equipment Use Please note: Your Truma Space Heater front is now attached using 2 screws. These screws must be removed prior to removal of the Space Heater front. These screws can be seen when looking into the fire through the air vents. TRUMA ULTRASTORE WATER HEATER This water heater features a dual source system of water heating powered by Liquid Petroleum Gas or 230V mains electricity. For a faster heating up period the appliance can be simultaneously operated with gas and electricity.
TAPS KITCHEN TAPS Your new Explorer Group Motorhome will be fitted with a Reich mixer tap. OPERATION For correct operation of the tap swivel the spout to the desired position over the sink. Lift the control lever to activate the pump and allow water to flow simultaneously. To adjust the temperature, swivel the lever to the left to increase the temperature and to the right to reduce the temperature.
Equipment Use CLEANING OF ALL TAPS It is recommended that a non-abrasive damp cloth be used for cleaning the Elegance taps and showers.
REFRIGERATOR OVEN HOB & GRILL SMOKE ALARM For full operational instructions for your particular fridge, refer to refrigerator manufacturer's instructions supplied with the appliance. For full operational instructions, refer to oven or hob & grill manufacturer's instructions supplied with the appliance. The smoke alarm fitted to your motorhome is approved for use in motorhomes. When the motorhome is being driven, the refrigerator should only be operated electrically, i.e.
Equipment Use NOTE: A different smoke alarm to the one illustrated may be fitted (subject to availability) but it still meets the criteria above. For further information on use of the alarm, battery replacement, testing, etc., refer to the manufacturer's literature contained in the Owner's Information Pack.
THETFORD CASSETTE TOILET Your motorhome is fitted with a cassette toilet. For full operational instructions, refer to the cassette toilet instruction manual in your Owner's Information Pack. EMPTYING THE TOILET 1. Open outer locker door and release bottom or base catch securing cassette. 2. Remove cassette, ensuring the flap is in the closed position (it is useful to use a trolley for taking waste tanks to the disposal point). 3.
Equipment Use AIR CONDITIONING WARNING! Never place your hands or other objects within the air inlet openings BLIZZARD 1500 AIR CONDITIONING UNIT (WHERE FITTED) Starting and Function Selection 1. Internal temperature thermostat. MAINTENANCE To ensure trouble-free running it is recommended that the unit be cleaned once or twice a year by a qualified service agent. control 2. Two speed fan switch. 3. On button (push to ON position). 4.
ROOFLIGHTS Your motorhome is fitted with at least one type of the following rooflights. Please note: Do not change the direction of the fan unless it has been switched off ‘O’ position and the blades have stopped rotating. c. Swivel the metal bar towards the glass dome and snap into its holder. d. To close the glass dome, proceed with steps (a-c) in reverse order. THE OMNIVENT (12V) ROOFLIGHT The Omnivent is a double-glazed rooflight constructed from a synthetic ultra-violet screened material.
Equipment Use of the glass (see 1a). b) Using both hands on the two toggle catches, press the glass dome up about 2cm and fasten the toggle catches in the corresponding setting. c) To close, proceed with steps (a-b) in reverse order. 4. Closing the blinds: a) Take hold of the end rod (without rocker) in the recessed grip and engage in the opposite end rod (with rocker). b) Select the required position (blackout/flyscreen) by moving both joined end rods together.
Should you decide to retro fit this product we would accecpt no liability for problems that may arise from altering the vehicle from its original specification.
Equipment Use WINDOWS Your motorhome will be fitted with either Polyplastic, Seitz flush windows, or a mixture of both. POLYPLASTIC WINDOW OPENING In order to open the Polyplastic window it is only necessary to move the catch upwards and release the catch from the backing plate. SEITZ WINDOW OPENING In order to open the Seitz window you must depress the button on the catch before moving the catch. Failure to do so will lead to the catch breaking.
DOORS EXTERIOR DOORS The exterior door can be secured to the side of the motorhome by pushing the the door retainer into the spring clip. To comply with European Standards, the exterior door lock must not be replaced with a double dead lock. INTERNAL DOORS The washroom door is fitted with a twoposition push button lock. From the outside, push once to lock. Push again to release. From the inside of the washroom you will need to pull the handle towards yourself to lock the door.
Equipment Use BED MAKE UP CASTAWAY AND AUTOSTRATUS D A B C AUTOCIRRUS AND CALYPSO Step 1 Lift up bed flaps located at the end of B and C. Step 2 Pull out the bed slats located underneath F and fully extend as shown. Step 3 Place cushions as shown in the diagram. Step 6 Step 7 Place cushions on the bed as shown in diagram Push the side retainers in to achieve a tight fit. Cushion E stored in over head cab.
A B C D AVANTGARDE AND AUTOQUEST 400RL Step 1 Remove cushion (E) Step 2 Slide out the bed slats from under the rear seat (C) Step 3 Place cushions on beds as shown. E AVANTGARDE AND AUTOQUEST 600 Step 1 Lift up bed flaps located at the end of B and C. Step 2 Pull out the bed slats located between B and C and fully extend as shown. Step 3 Place cushions as shown in the diagram. Please note Cushion F is a plain make up cushion supplied seperately.
Equipment Use MANU Operating the System 1. Switch ON the Power Pack and the red LED will illuminate. 2. Check the gain control switch is set to the normal NML position (switch UP). See Interference 2 over the page for use. 3. Push the Antenna Dome into position, ensuring it is properly seated in the Mounting Foot. Secure by tightening the two grub screws with the Allen Key. 9.
MANU Travelling Removing the Antenna DO NOT TRAVEL:With the Antenna raised With the Antenna set for vertical signals With the Telescopics extended When travelling adjust the antenna so that it points to the rear of the vehicle to reduce the possibility of damage when travelling. The RED SPOT on the bottom of the mast indicates the front of the Antenna. A permanently fitted Status can be easily removed leaving only the Mounting Foot and rubber gaiter. 1. Unplug the antenna from the Power Pack. 2.
Equipment Use FAULT FAULTFINDING FINDING The following are some of the key areas we suggest you check which generally solve the most common problems encountered with the operation of the Status antenna. Coaxial Plugs It is critical that all coaxial plugs in the system are fitted correctly. Using the diagram and procedure described over the page, please check each individual plug ensuring it is wired correctly. Secondly please ensure only quality plugs have been used.
Care & Maintenance CARE OF YOUR MOTORHOME This section of the guide is devoted to the care, cleaning and general preservation of your motorhome in order to retain its showroom condition. CLEANING Under no circumstances should an abrasive or harsh cleaner be used. Do not use a pressure wash as this can disturb mastic seals. Exterior Painted Body Part of the exterior of your motorhome, usually the side walls, is acrylic finished aluminium, which is extremely durable and easy to clean.
ACRYLIC WINDOWS Your motorhome is fitted with shatter resistant acrylic windows. To preserve their clarity and unblemished transparency it is essential that the following cleaning instructions are strictly adhered to: Road grit, dust, sand, flies, lime tree secretions, bird droppings etc., should be washed off using plenty of cold water. Any remaining dirt should be washed off using a soft cloth and warm water.
Care & Maintenance susceptible to contamination by bacteria if care is not taken with their use and cleaning. The symptoms caused by bacterial contamination are not purely limited to gastro-intestinal diseases, but may also manifest themselves as ear, nose, throat, eye or skin infections. It is therefore important that you carry out the following procedure prior to using the motorhome each time, even if you boil or filter all water you use for drinking. WATER CONTAINERS 1.
Suitable sterilising chemicals are available from your Explorer Group Retailer, accessory shop, chemists, or home-brew shops. It is not, however, recommended to use bleach or sodium metabisulphide.
Storage STORAGE If the motorhome is to be stored for any length of time, especially over the winter period, the following operations are recommended: Remove all linens, blankets, cushions, clothes, mattresses, etc. which could be affected by damp conditions. Clean the motorhome inside and out as detailed in the previous section. Drain the water system (see index). Ensure all windows, roof lights and doors are correctly fastened. Check fixed ventilation apertures are not obstructed.
Warranty WARRANTY 3-YEAR MANUFACTURER'S WARRANTY Subject to the following conditions, your motorhome is supplied with a manufacturer's warranty for 3 years from the original date of purchase, at no additional cost to you the customer. We sincerely hope you will never have cause to complain about your motorhome. However, if you do have a problem then please contact your retailer so they can report this through our warranty system.
EXPLORER GROUP 3-YEAR MANUFACTURER'S WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS: 1. The duration of the warranty is 36 months from the original date of purchase. 2. That the original construction of the motorhome has not been tampered with or repaired other than by Explorer Group or an approved retailer or Service Centre. 3. That an "annual" service, damp and safety check has been carried out by an approved retailer or Service Centre.
Code of Practice - Water Ingress CODE OF PRACTICE WATER INGRESS At Explorer we want our customers to be sure that, in buying one of our motorhomes, you are buying the very best. We would like you to continue to believe this for a long time after you have made your purchase. We are confident that our new motorhomes, built with innovative manufacturing techniques and tested materials, make water ingress concerns unnecessary.
Customer Obligation - Servicing SERVICING It is a condition of your warranty that your motorhome must have an annual habitation service, damp and safety check and this should be carried out by an Explorer Group approved retailer or Service Centre, in accordance with NCC guidelines. Proof of this will be required in the event of a warranty claim. Failure to do so will invalidate your warranty. The first service is due 60 days either side of the anniversary of the original date of purchase.
All such work should be undertaken using only approved Explorer Group genuine parts recommended sealant and following Explorer Group procedures. Explorer will also undertake to supply certain specialist repairers with the necessary spare parts. In this case, your selected repairer must contact the PARTS DEPARTMENT with all enquiries.
Motorhome Construction - Main Components MAIN COMPONENTS The following is a brief description of the main components used in your motorhome. More comprehensive descriptions can be found in the equipment manufacturers literature held in the Owner's Information Pack. BODY SHELL Motorhome bodies are constructed from the highest quality materials. The floor is constructed from a W B P plywood sandwich, impregnated with anti- damp and rot compounds and adhesives.
Equipment Lists 68 AUTOQUEST/AVANTGARDE AUTOCIRRUS/CALYPSO FRIDGE RM7270 FRIDGE RM7271 HEATER TRUMA S 3002P PIEZO HEATER TRUMA S 3002A AUTO INTERNAL BLOWN AIR SYST (OPTION ONLY) TRUMA ULTRAHEAT INTERNAL BLOWN AIR SYST TRUMA ULTRAHEAT WATER HEATER TRUMA ULTRASTORE 10LTR WATER HEATER TRUMA ULTRASTORE 10LTR SINK & DRAINER SPINFLO TOP FIX SINK & DRAINER SPINFLO ARGENT OVEN UNIT (OPTION ONLY) CAPRICE 20 20 OVEN UNIT MIDI PRIMA HOB UNIT 20 20 MINI GRILL HOB UNIT SPINFLO ARGENT TAPS
AUTOSTRATUS/CASTAWAY FRIDGE RM7291 HEATER TRUMA S 3002A AUTO INTERNAL BLOWN AIR SYST TRUMA ULTRAHEAT WATER HEATER TRUMA ULTRASTORE 10LTR SINK & DRAINER SPINFLO ARGENT OVEN UNIT MIDI PRIMA HOB UNIT SPINFLO ARGENT TAPS KITCHEN REICH TREND SHOWER EQUIPMENT REICH AT MIXER TAPS VANITY REICH TREND WATER FILTER/PUMP UNIVERSAL LIGHTS 12V CEILING/LOCKER CROWN / LUMO / NOVA LIGHTS 12V READING MICRO LIGHTS CONTROL PANELS CBE PC-200 ELECTRIC FITTINGS CBE / CLIPSAL CASSETTE BLINDS SEITZ T
Electrical Wiring Diagrams 12V & 230V AUTOQUEST 70
Electrical Wiring Diagrams 12V & 230V Explorer Group 2005 Motorhome Handbook AVANTGARDE 71
Electrical Wiring Diagrams 12V & 230V AUTOCIRRUS 72
Electrical Wiring Diagrams 12V & 230V Explorer Group 2005 Motorhome Handbook CALYPSO 73
Electrical Wiring Diagrams 12V & 230V AUTOSTRATUS 74
Electrical Wiring Diagrams 12V & 230V Explorer Group 2005 Motorhome Handbook CASTAWAY 75
Technical Specifications AUTOQUEST/AVANTGARDE TECHNICAL SPECIFICATIONS 2005 STANDARD ENGINE SIZE 100 200 Base Vehicle No. of Berths/Designated Passenger Seats Overall Exterior Length Overall Width incl. Wing Mirrors Overall Body Width Overall Height Maximum Internal Headroom Maximum Interior Width Tyre Size: Standard Tyre Tyre Pressure Front/Rear Bed Sizes PEUGEOT (290SWB) 2.0HDi 4/3 5490mm (18’0”) 2530mm (8’3.5”) 2200mm (7’2.5”) 2895mm (9’6”) 2145mm (7’.5”) 2074mm (6’9.
CALYPSO/CASTAWAY TECHNICAL SPECIFICATIONS 2005 CALYPSO Base Vehicle Base Vehicle Spec. Chassis Convertion Extra Suspension Upgraded Tyres No. of Berths/Designated Passenger Seats Exterior Length Overall Width incl. Wing Mirrors Overall Width Overall Height Maximum Headroom Interior Width Tyre Size Tyre Pressure Front Rear Bed Sizes Maximum Front Axle Weight Maximum Rear Axle Weight M.T.P.L.M. Mass in Running Order Essential Habitation Equipment Maximum User Payload PEUGEOT (330) 2.
Technical Specifications AUTOCIRRUS/AUTOSTRATUS TECHNICAL SPECIFICATIONS 2005 AUTOCIRRUS Base Vehicle Base Vehicle Spec. Chassis Convertion Extra Suspension Upgraded Tyres No. of Berths/Designated Passenger Seats Exterior Length Overall Width incl. Wing Mirrors Overall Width Overall Height Maximum Headroom Interior Width Tyre Size Tyre Pressure Front Rear Bed Sizes Maximum Front Axle Weight Maximum Rear Axle Weight M.T.P.L.M.
Frequently Asked Questions (FAQs) GENERAL QUESTIONS Q: WHERE IS MY NEAREST RETAILER? Q: WHERE CAN I OBTAIN YOUR LATEST BROCHURE? A: Our latest brochures are available from Approved Retailers or can be viewed and printed from the downloads section on our website www.explorer-group.co.uk. A: Please refer to our Find A Retailer section on our website- www.explorergroup.co.uk, or telephone 01207 699 000 and ask for Customer Services.
Q: I REQUIRE TECHNICAL OR OTHER INFORMATION, WHO CAN HELP ME? A: The majority of information you require is available through your Explorer Group Retailer. Should you need to contact Explorer Group Customer Services, then please quote the serial number of your motorhome, along with your full name and address if a written reply is required. Q: CAN YOU TELL ME THE SECOND HAND PRICE OF MY MOTORHOME? A: Unfortunately as a manufacture we are not involved in the second hand market.
Frequently Asked Questions (FAQs) TECHNICAL RELATED QUESTIONS Q: WHAT ARE THE SPECIFIED WEIGHTS FOR MY MOTORHOME? A: Your motorhome, MTPLM, MIRO, Essential Habitation Equipment, Maximum User Payload, Maximum Hitch Weight and Optional Equipment Payload can all be found by looking in the latest model section, or the 'Product Archives' on our website or referring to the relevant Technical Specification section of this handbook.
the 12v supply of your battery, a 10W bulb will use just over 0.8A (though probably nearer to 0.9A due to losses in the wiring etc), a 60W portable TV around 5A; and a 30W circulation fan on a heating system around 2.5A Your water pump will also use a little, but it is not on for long. A night might go like this: 3 x 10W lamps for 5 hours = 13.5Ah; heater fan in use for 10 hours = 25Ah; TV on for 3 hours = 15Ah. So the total usage would be 53.Ah.
Frequently Asked Questions (FAQs) PARTS RELATED QUESTIONS Q: WHERE CAN I GET SPARE PARTS FOR MY MOTORHOME? A: We do not supply spare parts direct to the public at present, but our network of Retailers will be able to source most parts you require. For details of your nearest Explorer Group Retailer please refer to our Find A Retailer section on our website or call 01207 699 000 for assistance. In addition there are companies that buy up old stock and they may be able to assist you.
WARRANTY RELATED QUESTIONS Q: DOES MY MOTORHOME HAVE A WARRANTY? A: Yes. Our warranty arrangements are as follows: If the original date of purchase is on or after 1 September 02, your motorhome conversion is supplied with a 3 year manufacturer's warranty, details of which can be found in your owner's handbook. In addition, there is also a 5-year water ingress Code of Practice. All warranties are dependant upon compliance with the relevant terms and conditions, particularly regarding annual servicing.
Frequently Asked Questions (FAQs) Q: WHO CAN SERVICE MY MOTORHOME? A: We would always recommend that an approved Explorer Group Retailer, or Service Centre undertakes the annual service. However, we will accept services completed by a Jones Vening approved company.
ABBREVIATIONS USED ISO International Standards Organisation KG Kilogram KPH Kilometres per hours LI Load Index LPG Liquefied Petroleum Gas LTRS Litres Mbar Milibar ABS Description AC Alternating Current BS British Standards CC Motorhome Club CCC Camping and Motorhomening Club CM Centimetres MCB Miniature Circuit Breaker CMHR Combustion Modified High Resilient MIN Motorhome Identification Number (MINDER) CORGI Confederation of Gas Installers MIRO Mass In Running Order MM
Frequently Asked Questions (FAQs) GLOSSARY out through a number of outlets. ABS An acronym for anti-lock braking system BUNK BED A sleeping place, usually higher up than a conventional bed. Often (but not always) this can be folded or removed to provide additional living space. ACTUAL LADEN WEIGHT The total weight of the motorhome when loaded ready for use by the end user. AQUAROLL Brand name used generically for a water container that rolls so you don’t need to lift it.
ESSENTIAL HABITATION EQUIPMENT Those items and fluids required for the safe and proper functioning of the equipment for habitation as defined by the manufacturer of the motorhome. This includes items such as the leisure battery and gas cylinders, plus water contained in the water heater etc. FLYSCREENS Mesh fittings for windows doors and roofvents, to keep out insects etc. FREE-STANDING TABLE A table which, because of its leg design, can be used inside or outside.
Frequently Asked Questions (FAQs) LEVEL The process of ensuring that a motorhome is level when sited on a pitch. Important for comfort and also to ensure the correct functioning of the fridge and water systems. LPG Liquid Petroleum Gas, i.e. butane or propane. L-SHAPED A term where the seating area of a motorhome is indeed L-shaped. 90 any part of the user payload, including the essential habitation equipment.
ROOF VENT An opening unit in the ceiling which lets in light and air. These vary in size, but the best ones will have integral blinds and flyscreens. Also called rooflights. SEMI-RIGID PIPEWORK Usually, a reference to the water system; infinitely preferable to cheaper convoluted piping which can act as a trap for germs and smells.. SLATS Sometimes used for beds. Improves ventilation to mattress cushions. SPACE HEATER Type of heating equipment for the living quarters.
Index A Abbreviations Used ABS Panels Cleaning ABS Wheel Spats Cleaning Acrylic Window Cleaning Additional Security Air Conditioning Air Conditioning Fitting Alarm - Anti Tamper Features Alarm - Preparation for Use Alarm - Product Specifications Alarm - Testing Alarm - Using Alarm System Annual Service Annual Service Record Automatic Igniter - Gas Heater Autocirrus/Calypso Automatic Igniter - Gas Heater Autostratus/Castaway Awning Spaces/Ventilation 92 87 55 55 55 27 42 82 29 28 29 28 28 28 85 96 34 34 17
F Filling Your Onboard Water Tank Fire Extinguishers Fire Retardant Foams Fire Safety Fitting Accessories Flyscreens Frequently Asked Questions Furniture Cleaning Fuses 14 25 25 25 82 46 80 55 23 G Gas Gas Connection Gas Dispersal Holes Gas Heater Operation Gas Heater Operation Gas Hoses Gas Safety Advice General Safety Generators Generators Glossary Of Terms Grill GRP Cleaning 15 15 24 32 35 15 16 4 21 23 88 39 54 H Handbook Purchase Heki 2 Rooflight Heki 3 Rooflight Heki Duette Luxus Rooflight Hob 80
Index O Omnivent Oven Overcab Double Bed P Parts - Warranty Cover Payload Piezo Ignition - Gas Heater Autoquest/Avantgarde Polyplastic Windows Operation Power Drain Power Drain Power Needs Prepare Your Water System For Winter Use Preparing For The Road Propane R RCD - Resetting & Test Button RCD/MCB Protection Refrigerator Remedial Work and Vehicle Servicing Retailer - Find Retailer Special Editions Reverse Polarity Roof Blinds Roof Loading 94 43 39 49 60 6 33 46 21 58 82 14 6 15 22 22 39 64 80 99 23 46
V Ventilation - Bedrooms Ventilation - High Level Ventilation - Low Level VIN Number W Warranty Warranty Extension Warranty Terms And Conditions Wash Basin Cleaning Water Water Container Cleaning Water Heater - Draining Water Heater - Filling Water Heater Controls Water Ingress Water Pump Connection Water Pump Switch Avantgarde/Autoquest Water Pump Switch Mid/Premium Range Water System Cleaning Weights Weights Explained Welcome & Introduction Window Blinds Windows Winterisation - Motorhome Covers 24 24 24
Annual Service Record MOTORHOME ANNUAL SERVICE RECORD Your motorhome needs servicing at least once a year. Whether you use your motorhome for short journeys or for touring at home or abroad, regular servicing will help to ensure that you can enjoy it to the full. The Annual Service offered by your Retailer will include the following work and it is our recommendation you have your motorhome serviced to this standard annually.
ANNUAL SERVICE RECORD MOTORHOME MODEL ............................................................................................................................................................................... VEHICLE IDENTIFICATION NUMBER ................................................................................................................... YEAR ..........................
Annual Service Record 98 7th SERVICE 8th SERVICE 9th SERVICE DATE: DATE: DATE: RETAILER’S STAMP RETAILER’S STAMP RETAILER’S STAMP I/We certify that an annual service has been carried out in accordance with the manufacturer’s and National Caravan Council recommendations. I/We certify that an annual service has been carried out in accordance with the manufacturer’s and National Caravan Council recommendations.
2005 EXPLORER GROUP RETAILER SPECIAL EDITIONS PARENT MODEL RETAILER SPECIAL PARENT MODEL RETAILER SPECIAL AVANTGARDE XPEDITION AMAZON GT SUNTOR CLASSIQUE SUNSEEKER AUTOQUEST FIRESTORM SUNTOR Retailer Special Editions Explorer Group 2005 Motorhome Handbook ALL EXPLORER GROUP MOTORHOME RETAILER SPECIALS ARE BASED ON OUR CURRENT BASE MODELS.
Notes 100
Notes Explorer Group 2005 Motorhome Handbook 101
Notes 102
Notes Explorer Group 2005 Motorhome Handbook 103
Notes 104
All the illustrations and descriptive matter in this guide are intended to give a general idea of the motorhome. Changing market and supply situations may prevent the manufacturer from maintaining the exact specifications and details in this handbook and we therefore reserve the right to alter specifications and materials as conditions demand. Retailers are independent of the manufacturer and have absolutely no authority to bind the manufacturer by any express or implied undertaking or representation.
