Value Zentec Hybrid Air Capsulate Value Iron Filter - Sulphur Filter Installation Manual Barrie, Ontario, Canada L4N 8W8 www.excaliburwater.
EXCALIBUR VALUE IRON FILTER - SULPHUR FILTER INSTALLATION MANUAL INSTALLATION PROCEDURES: The Value Iron Filter - Sulphur Filter control valve, fittings and chemical free bypass are designed to accommodate minor plumbing misalignments. Do not use Vaseline, oils, hydrocarbon lubricants or spray silicone on the Value Iron Filter - Sulphur Filter. A silicon lubricant may be used on back o rings of the Value Iron Filter - Sulphur Filter but not necessary.
All plumbing should be done in accordance with local plumbing codes. The pipe size for Value Iron Filter - Sulphur Filter drain line should be a minimum of ½ inch. When the backwash flow rates for the Value Iron Filter - Sulphur Filter in excess of 7 GPM or length in excess of 20 feet this now requires a ¾ inch drain line. Solder joints near the Value Iron Filter - Sulphur Filter drain must be done prior to connecting the Value Iron Filter - Sulphur Filter drain line flow control fitting.
Do not use a pipe wrench to tighten Value Iron Filter - Sulphur Filter nuts on installation fittings. Hand tighten only. Value Iron Filter - Sulphur Filter split ring retainer holds the nut on and allows load to be spread over the entire nut surface area reducing the chance for leakage with the Value Iron Filter - Sulphur Filter. The split ring design, incorporated into the Value Iron Filter Sulphur Filter installation fittings allows approximately 2 degrees off axis alignment to the plumbing system.
Programming Set Up Iron Filter - Sulphur Filter Filters On the Value Iron Filter - Sulphur Filter press next and buttons simultaneously for 3 seconds and release to take go to the Value Iron Filter - Sulphur Filter regeneration and cycle times set up screens. Step 1: The first Value Iron Filter - Sulphur Filter set up stage will have a arrow pointing to the SET on the top left and the display on the digital board should read “Soft”. Press the Value Iron Filter - Sulphur Filter next button to go to step 2.
Step 6: On the Iron Filter - Sulphur Filter next setting will have an arrow pointing to the SET on the top left with another arrow pointing to the fill. This is a fill cycle which is not required on the Value Iron Filter Sulphur Filter and should be set to “OFF”. Press the Value Iron Filter - Sulphur Filter next button to go to exit and return to time.
Filter - Sulphur Filter regeneration is to occur today, an arrow will point to regeneration on the Value Iron Filter - Sulphur Filter. For immediate regeneration simultaneously press and hold the REGEN button for 3 seconds on the Value Iron Filter - Sulphur Filter. When the Value Iron Filter - Sulphur Filter is in regeneration, step through the different regeneration cycles by pressing the Regen button on the Value Iron Filter - Sulphur Filter until complete and back to present time of day.
EXCALIBUR WATER SYSTEMS Value Iron Filter - Sulphur Filter Troubleshooting Guide Problem 1. Timer does not display time of day 2. Timer does not display correct time of day 3. Control valve regenerates at wrong time of day Possible Cause a. Transformer unplugged b. No electric power at outlet c. Defective transformer d. Defective PC board a. Switched outlet b. Power outage c. Defective PC Board a. Power outages b. Time of day not set correctly c. Time of regeneration incorrect a.
6. Control valve does not regenerate automatically when UP and DOWN buttons are depressed and held 7. Control valve does not regenerate a. Transformer unplugged b. No electric power at outlet a. Connect transformer b. Repair outlet or use working outlet c. Broken drive gear or drive cap assembly d. Defective PC board c. Replace drive gear or drive cap assembly d. Replace PC board a. Defective PC board b. Set-up error a. Replace PC board b.
7 YEAR WARRANTY Lifetime Tank Warranty Value Iron Filter - Sulphur Filter Thank you for your purchase of our VALUE IRON FILTER - SULPHUR FILTER. For proof of purchase, please retain your Invoice/Sales Order Copy. Warranty ~ Offered Excalibur Water Systems warranties its products to be free from defect in materials and workmanship to the original owner from the date on the proof of purchase as described below.
