SDS

Engineering Measures:
Individual protection measures:
Respiratory Protection:
Wear protective clothing to prevent repeated or prolonged contact with product. Protective clothing needs to be
Technical measures and appropriate working operations should be given priority over the use of personal protective
None needed under ambient conditions with adequate local exhaust. Always use an approved respirator when vapors
8.2 Exposure controls
equipment. Use adequate ventilation. Local exhaust is preferable. Refer to section 7.1.
Other protective equipment:
selected specifically for the workplace, depending on concentrations and quantities of hazardous substances handled. The chemical resistance
of the protective equipment should be enquired at the representative supplier.
clothing. Preventive skin protection is recommended. Wash hands thoroughly after use, before eating, drinking, smoking or using the lavatory.
Facilities storing or using this material should be equipped with an eyewash station and safety shower. Change contaminated
Wear protective goggles or safety glasses with unperforated side shields during use. Refer to 29 CFR 1910.133, ANSI Z87.1
Eye/face protection:
Hygiene measures:
Hand Protection:
Wear Nitrile rubber or Neoprene gloves or those recommended by glove supplier for protection against materials in Section 3.
Gloves should be impermeable to chemicals and oil. Breakthrough time of selected gloves must be greater than the intended use period.
Long sleeve shirts and trousers without cuffs; boots if the situation calls for them.
Page 3 of 6
SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES
9.1 Information on basic physical and chemical properties
Appearance Clear, colorless paste
Odor Acetic acid odor
Odor Threshold 2 ppm (Acetic acid)
Molecular Weight Not applicable
Chemical Formula Not applicable
pH No data available
Freezing/Melting Point, Range
Initial Boiling Point
No data available
Evaporation Rate No data available
Flammability (solid, gas) Not applicable
Flash Point
Autoignition Temperature
Decomposition Temperature No data available
Lower Explosive Limit (LEL) No data available
Upper Explosive Limit (UEL) No data available
Vapor Pressure
No data available
Vapor Density No data available
Specific Gravity
Viscosity
>100 °C (>212 °F), closed cup
1.007
No data available
No data available
No data available
Solubility in Water Negligible
Acetic Acid (CAS #64-19-7) is formed when this product contacts water or humid air. Provide adequate ventilation to control exposures within the
guidelines of OSHA PEL (10 ppm TWA) and ACGI TLV (10 ppm TWA; 15 ppm STEL).
or European Standard EN 166. It is recommended that contact lenses be removed before using this sealant. Do not handle lenses until all
sealant has been cleaned from the fingertips, nails and cuticles. Residual sealant may remain on fingers for several days and transfer to lenses,
causing severe eye irritation.
are generated. Where risk assessment shows air-purifying respirators are appropriate use a full-faced respirator with multi-purpose combination
(US) or type ABEK (EN 14387) respirator cartridges as a backup to engineering controls. If the respirator is the sole means of protection, use a full-
faced supplied air respirator. Use respirators and components tested and approved under appropriate government standards such as
NIOSH (US) or CEN (EU).
Environmental exposure controls:
Do not empty into drains.
PPE must not be considered a long-term solution to exposure control. PPE usage must be accompanied by employer programs to properly select,
maintain, clean fit and use. Consult a competent industrial hygiene resource to determine hazard potential and/or the PPE manufacturers to ensure
adequate protection.
EverKem Diversified Products
Not determinedPartition Coefficient: n-octanol/water
Oxidizing Properties Not applicable
TruSil 100 Silicone Sealant (Clear)
SECTION 10 - STABILITY AND REACTIVITY
Stable under recommended storage conditions.
10.2 Chemical stability
10.1 Reactivity
No special reactivity has been reported.
9.2 Other data
No data available
Explosive Properties Not applicable
No data availableVolatiles by Weight @ 21 ºF
VOC Content by Volume 30 g/l