DOWN UNDER SERIES INSTRUCTION MANUAL FOR MODELS DU95-DZ DU75-DZ
DOWN UNDER SERIES Please read operating manual carefully before using your unit. Please keep manual in a safe place. If lost you can find a digital copy at Evakool.com.au or contact Evakool on 1300 385 665 (1300 EVKOOL). Contents 1 Safety Instructions 2 Notes on Using the Product . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 3 Operation . . . . . . . . . . . . . . . . . . . . . . . . . .
DOWN UNDER SERIES 1 Safety Instructions • Warning: Do not touch exposed cables. • Warning: Do not use fridge if you suspect any connections could be wet. • When using the fridge in a vehicle, please ensure the circuit being used is fused at the battery or power source at the recommended size. • Any installation of DC power systems should be handled by a qualified professional. • Make sure the source voltage is correct. The technical data label (page 13) has the voltage data.
DOWN UNDER SERIES RECOMMENDED TEMPERATURE SETTINGS Fridge 2°C Freezer -16°C COMPRESSOR SPEED SETTINGS Eco Recommended for ambient temperatures of 30°C or less. Max Recommended for ambient temperatures of 30°C or more. For Maximum Efficiency • Use the included baskets to ensure air circulation freely around the cabinet. • Ensure the vents are not obstructed as to allow maximum airflow. • Refrain from unnecessary opening of the unit. 3.
DOWN UNDER SERIES LED Control Panel LED Display +/- Buttons SET Button 1. On/Off Button Display Error message will display here ROOM 1 - Larger Bin Temperature Max or Eco Mode ROOM 2 - Smaller Bin Automatically set to Celsius. Fahrenheit not available. Battery Protection Mode 2. To turn on/off the refrigerator: • Hold the button for one to two seconds. 3. Setting the temperature: • To set Room 1 press button once. • To set Room 2 press button twice.
DOWN UNDER SERIES 4. Setting the Max or Eco mode: • Press the button 3 times. • Use the or buttons to select mode. • After a few seconds, the selected mode will automatically set. 5. Setting the battery protection mode: • Press the button 4 times. • Use the or buttons to select the battery protection mode. Modes available: - Low - Medium - High • After a few seconds the selected mode will automatically set.
DOWN UNDER SERIES 4. Connecting the Refrigerator Connecting to a battery • The fridge can be operated with 12V or 24V. • Note: disconnect the fridge (and other consumer units) from the battery before you connect the battery to a quick charging device. Over voltage can damage the electronics of the device. • For safety reasons the refrigerator is equipped with an electronic system to prevent polarity reversal. This protects the fridge against short-circuiting when connected to a battery.
DOWN UNDER SERIES 5. Error Codes Code Reason / Solution E1 Low Voltage • Please check the source voltage to ensure it is above the cut out. Try lowering the voltage cut out setting to LOW (refer to page 7). • The vehicle cabling may be inadequate/unsuitable, please refer to cable specifications table for correct cable thickness (page 5). • Try on a different power source. E2 Fan Issue • Fan is drawing too many Amps (Over 1 Amp). - Contact EvaKool E3 Compressor Start Issues • Unplug for 10 minutes.
DOWN UNDER SERIES 6. Preventative Maintenance & Care: Metal & Injection Moulded Products To ensure a long life and reliable operation of your metal and injection moulded fridge/ freezer we recommend following our preventative maintenance and care guide. Cabinet Care • The cabinet should be cleaned after every use by wiping both the interior and exterior with a damp cloth, using a mild non-abrasive detergent, and dry thoroughly. The painted metal surfaces can be polished with a car polish and a soft cloth.
DOWN UNDER SERIES 7. Troubleshooting The appliance is not turning on • Check the power supply. • Check whether the plug and the socket have a good connection. • If you have purchased an additional 12V adaptor with a cigarette end, check whether the fuse requires replacing. This is located inside the cigarette end of the 12V adaptor. Follow the ‘Replacing the fuse plug’ section at the bottom of page 11 if you require a new fuse. • Check whether the appliance has been turned on (refer to page 6).
DOWN UNDER SERIES • • • • • Unscrew the screw from the upper half of the housing. Carefully raise the upper half of the housing from the lower half. Take out the contact pin. Replace the defective fuse with a new one that has the same rating (10A, 250V). Re-assemble the plug in the reverse order. Replacing the PCB (display) light • If you require a new PCB light please contact Evakool on 1300 385 665. Spare part code: LED-DU. • The PCB light is located internally on the outer left and right hand sides.
DOWN UNDER SERIES 8. Product Data SPECIFICATIONS Model No. DU75-DZ DU95-DZ Basic Data Type DC + Adaptor Cooling △T °C 43°C Temperature Range Refrigeration °C +10°C to -18°C Gross Capacity L Power Supply V DC 12/24V Rated Current DC A 5.4A/2.7A Rated Power Input W 65 Sound Noise Level dB 45 Foaming Thickness mm 50 75 Temperature Control 95 Digital Control (NTC) Refrigerating System Compressor Brand SECOP PCB 2.
DOWN UNDER SERIES 9. Product Drawings DU75 Internal Dimensions External Dimensions 530.
DOWN UNDER SERIES DU95 Internal Dimensions External Dimensions 575.
DOWN UNDER SERIES 10. Warranty Statement/Terms & Conditions Nexberg Pty Ltd trading as EvaKool undertakes to the original purchaser that this product is sold free of defect in materials and/or workmanship under normal use for a period of 3 years. Subject to the following: • The warranty period commences from the date of purchase by the original purchaser from an authorised EvaKool dealer. • The Secop compressor in this unit carries a 5 year warranty under normal use.
DOWN UNDER SERIES 17
DOWN UNDER SERIES 18
For your nearest stockist contact Evakool T: 1300 385 665 (1300 EVKOOL) E: sales@evakool.com evakool.com.au For Service and Warranty support contact Evakool T: 1300 385 665 (EVKOOL) E: warranty@evakool.
