SDS

ManualsBrandseufy Security ManualsSmart DevicesSoloCam S40 Wireless Home Security Outdoor Surveillance Spotlight Camera 2K HD

Guangdong Pow-Tech New Power Co.,Ltd.

MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 1/13



广东力科新能源有限公司

Guangdong Pow-Tech New Power Co.,Ltd.



PRODUCT SPECIFICATION

产品规格书

CONFIDENTIAL



Customer:

Model Name:

INR18650F1L(1INR19/66-4)

Battery P/N:

Client P/N: T8124

Description: Rechargeable Lithium-ion Battery Pack

Principal/制定

Checked/审核 Approval/批准

袁春华晋文章王友伟

Customer Approval

客户回签

地址:深圳市福田区上梅林中康路卓越梅林中心广场南区 A 座 903 室。

ADD:Room903, Tower A,ZhuoyueMeilin central square（South district）,Zhongkang Road, Shangmeilin

area, Futian District, Shenzhen.

工厂: 东莞市寮步镇横坑石岭工业区横东三路 9 号。

Factory:No.9,Hengdong 3 Road,HengkengShiling industry Zone,liaobu Town, Dongguan.

Summary of content (13 pages)

PAGE 1
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 1/13 广东力科新能源有限公司 Guangdong Pow-Tech New Power Co.,Ltd.
PAGE 2
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 2/13 Revision History 修订履历 No.
PAGE 3
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE TABLE OF CONTENTS 目录 1. Application 适用范围 .................................................................................................. 4 2. Battery Pack Overview 电池组概述 ............................................................................. 4 3. Battery pack outline dimensions 电池组外形尺寸......................................................... 5 4. Battery pack Specifications 电池组规格 .................................
PAGE 4
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 4/13 1. Application 适用范围 The specification is applicable to Guangdong Pow-Tech New Power Co., Ltd. with basic performance, technical requirement, testing method, warning and caution of the rechargeable Lithium-ion battery. 本规格书规定了可充电锂离子电池的基本性能、技术要求、测试方法及注意事项，本标准只适用于广东力科新能源有限公司。 2. Battery Pack Overview 电池组概述 2.
PAGE 5
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 5/13 3. Battery pack outline dimensions 电池组外形尺寸成品尺寸图 battery dimensions Label 标签 4. Battery pack Specifications 电池组规格 Item 项目 No Specifications 规格 Nominal Capacity （Typical） 4.1 Capacity 容量 From FC voltage to FD 13000mAh 标称容量（典型） Minimum Capacity 最小容量(Cmin) Remark 备注 voltage by discharge current 0.2C at 25℃ ± 3℃.
PAGE 6
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) Nominal voltage 4.2 VER A1 PAGE 6/13 3.63V 标称电压 Charging Method CC-CV 充电模式 Full Charging(FC)Voltage 4.2V Upper limited charge voltage 最高充电电压 Standard Charging 4.3 Charge 充电 Current 0.2 Cmin 标准充电电流 Max Charging Current 3000mA Continuously 最大持续充电电流 Standard Charging method 标准充电模式 0.2 Cmin CC charge to 4.2V,then CV charge till charge current decline to 50mA 以 0.2 Cmin CC 恒流充电至电压 4.20V，然后以 4.
PAGE 7
Guangdong Pow-Tech New Power Co.,Ltd. MODEL 4.8 INR18650F1L(1INR19/66-4) AC Impedance VER ≤100mΩ 交流内阻 A1 PAGE 7/13 1KHz AC Method As of shipment 4.9 （status of the delivery） 3.50V-3.75V 出货状态（Pack Voltage 电池组电压） 4.10 4.11 4.12 Operation mode consumption <10uA current/正常模式下功耗 Cycle Life >70% after500 cycles 循环寿命 ESD static test/静电测试 See 9.2 Electrical Performance For Detail Air discharge ±8KV Contact discharge ±4KV 5. PCBA Protect Function 保护功能 NO Items/目录 Criteria/标准 5.
PAGE 8
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 8/13 6. Schematic 电路原理图 7. PCB Layout PCB 板图 Top Layer TBD Bottom Layer TBD 8. Key Electronic Components 关键元器件 Item Symbol Description 8.1 U1 Protect IC 8.2 Q1,Q2 Power MOSFET 8.3 RT1 NTC 8.4 R3 ID Resistor 8.5 F1 PTC 8.
PAGE 9
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 9/13 9. Battery Electronic Characteristics 电性能特性 Standard environmental test condition. Unless otherwise specified, all tests stated in this Product Specification are conducted at below condition: Temperature : 25℃ ± 3℃, Humidity: 60 ± 20% 标准环境试验条件。除非另有规定，否则本产品规范中规定的所有试验均在以下条件下进行：温度：25℃ ± 3℃；湿度：60 ± 20%。 No. 9.1 9.2 9.3 9.
PAGE 10
Guangdong Pow-Tech New Power Co.,Ltd. MODEL 9.5 10. INR18650F1L(1INR19/66-4) ESD Test VER A1 Method: 5 times/pin , Frequency:1S/time Non-operating: Contact: ± 4KV ;Air: ± 8 KV 对电池组每个端子或者电路板的输出端子进行±4KV 接触放电测试各 5 次和±8KV 空气放电测试各 5 次，每两次放电测试时间间隔 1 分钟. PAGE 10/13 No explosion and no fire. Its protection function shall not fail. if it is equipped with protection circuit. 电池组应不起火、不爆炸，如有保护电路其保护功能不应失效。 Reliability Test 可靠性测试 No. 10.1 10.2 10.3 10.
PAGE 11
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 11/13 within 30 minutes and maintaining this temperature for 2 hours. E: Repeating the sequence for a further 10 cycles. 电池应放置在测试温柜中，并进行下列循环： A: 30 分钟内将温柜温度提高到 70±3℃，维持 4 小时。 B: 30 分钟内将温柜温度降至 20±3℃，维持 2 小时。 C: 30 分钟内将温柜温度降至-40±3℃，维持 4 小时。 D: 30 分钟内将温柜温度提高到 20±3℃，维持 2 小时。 E: 重复这个测试 10 个周期。 10.
PAGE 12
Guangdong Pow-Tech New Power Co.,Ltd. MODEL INR18650F1L(1INR19/66-4) VER A1 PAGE 12/13 先恒流后恒压方式充电，禁止颠倒的方式充电。如果电池正负极颠倒充电会带来危险。 12.2 Discharge current 放电电流 The discharge current is not allowed to out of max current as specification. Otherwise, the battery will be over heat and capacity fading. 电池放电电流不能超过规格书规定的最大放电电流，过大的电流放电会造成电池发热和容量衰减。 12.3 Discharge temperature 放电温度 Please refer to the temperature range as specification. 电池放电温度必须按照规格书的温度范围执行。 12.
PAGE 13
Guangdong Pow-Tech New Power Co.,Ltd. MODEL          14. INR18650F1L(1INR19/66-4) VER A1 PAGE 13/13 Never short circuit the battery. 避免短路电池. Avoid excessive physical shock or vibration. 避免过分的物理震动和冲击电池. Do not disassemble or deform the battery. 不能拆解或使电池变形. Never allow the battery to get wet or be immersed in water. 不能将电池浸入水中. Do not use different types of battery together. 不能将其它不同厂家、类型、型号的电池混合使用. Keep away from children. 禁止小孩接触电池. Charge at the appropriate conditions. 电池必须在合适的条件下充电.