Service manual

Page 13 of 151
2.4 THROTTLE OPERATION
• Inspect for smooth throttle lever full opening and
automatic full closing in all steering positions.
• Ensure that there is no deterioration, damage,
or kinking in the throttle cable. Replace it if
necessary.
• Check the throttle lever. Free play is 5-10
mm at the tip of the throttle lever.
• Disconnect the throttle cable at the upper end.
• Lubricate the cable with commercially available
lubricant to prevent premature wear.
2.5 THROTTLE CABLE ADJUSTMENT
• Slide the rubber cap of the adjuster off the
throttle housing.
• Loosen the lock nut and adjust the free play of
the throttle lever by turning the adjuster on the
throttle housing.
• Inspect the free play of the throttle lever.
2.6 AIR FILTER
• Remove the four clips.
Remove the two screws inside the air
cleaner case.
• Remove the air filter element from the air
cleaner case. Soak the element in non-
flammable solvent. Squeeze out the solvent
thoroughly.
• Let it dry.
• Soak the filter element in gear oil and
then squeeze out the excess oil.
• Reinstall the components into air the cleaner.
Note: for more detail, see chapter 5-10
Throttle
Element
Copyright ©2008-2009 ETON America, llc., all rights reserved.
www.Get2itParts.com
www.Get2itParts.com
www.Get2itParts.com