COFFEE TECHNOLOGIES Instruction for use Nova Instant © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant Manufacturer: ETNA Coffee Technologies b.v. P.O. Box 200 7130 AE Lichtenvoorde The Netherlands Distributor: © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant COFFEE TECHNOLOGIES CONTENTS 1 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1.1 This user manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1.2 Pictograms and safety symbols on the machine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 1.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.5 Daily maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.5.1 Checking the ingredient containers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.5.2 Cleaning drip tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.5.3 Cleaning the mixers . . . . . . . . . . . . . . . . . . .
Instruction for use Nova Instant COFFEE TECHNOLOGIES 1 INTRODUCTION 1.1 This user manual Congratulations on the purchase of yourNova Instant. This machine has been developed and produced using state-of-the-art technology. This, combined with the ISO 9001 certification that applies to all our products, means you can rest assured that you are the owner of a high quality product.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 1.3 Pictograms and safety symbols in the manual These pictograms are used in the manual: Ꮨ h ☞ 1.4 General warning or caution. Damage to the machine or personal injury can occur. Electrical hazard Burning hazard Remarks, suggestions and advice Conventions and definitions Throughout the document, reference is made to the "left", "right", "front" and "rear" of the machine.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 1.6 1. 2. 3. 4. 5. 6. Machine identification on the exterior of the machine Model number Voltage Frequency Power rating Serial number Water pressure The identification plate is on the rear of the machine. 3 1 2 4 4A COFFEE TECHNOLOGIES Model: Voltage: Water: Nova/154/L a.c. 230v 50 Hz 2,31 kw 150 - 800 kPa ETNA Coffee Technologies BV Lichtenvoorde Holland 012540E1 5 6 Figure 1-4 1.7 1. 2. 3. 4. 5. 6.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 1.8 Used machines and the environment j a 1.9 Ask your local authority for information on ways to recycle materials safely and in an environmentally friendly manner. Ask your local authority for information on ways to dispose of materials safely and in an environmentally friendly manner.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 1.9.3 Users The daily, weekly and monthly maintenance and cleaning activities may only be carried out by users who have received training from the installer or owner of the machine. These individuals will be familiar with the potential risks of opening the machine. Staff who are still in training must be supervised when carrying out cleaning activities. This must be under the responsibility of an authorised user. 1.9.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 2 DESCRIPTION OF MACHINE 2.1 General description This machine prepares and dispenses various hot drinks. The drinks are dispensed in the cups intended for this purpose and that are placed on the machine cup stand. The cups must be placed on the cup stand manually. The display on the machine indicates that: • a drink can be selected • a drink is being prepared • a fault has occurred. 2.2 Main components 2.2.1 Front view 1. 2. 3. 4. 5. 6.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 2.2.2 Interior view 1 2 5 3 4 Figure 2-2 1. 2. 3. 4. 5. Ingredient containers Dispenser nozzle Mixer components Dispensing holder Service switch 11 © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 2.3 Container lay-out I43 I54 Figure 2-3 The different types are fitted with the following containers. Machine Instant container Nova I43 3x 2.3 L 1x 4.8 L Nova I54 2.4 5x 2.3 L Principle of operation After a selection is made, the drink is prepared and dispensed. • The water is supplied via the boiler (heated). • Instant products are dosed from the containers into the mixer and/or the ground coffee is dosed into the brewing group.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 2.6 Service key Figure 2-4 Once the service key has been inserted and turned a quarter turn, the machine is operational for repair and test purposes. 2.7 The machine contains rotating and moving parts. Ensure that your fingers do not become trapped when work is carried out.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 2.7.2 Selecting jug function If the jug function is switched on the cup sensor is switched off. The jug function allows you to select more than one cup at once. This button operates with all available drinks. The procedure for selecting more than one cup is described below. 1. Push the cup stand up and put a jug under the dispensing nozzle. 2. Use the jug function button and press the desired selection button several times. 3.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 3 USE 3.1 Safety instructions - use • • • • • • • • • • • • • • • Inspect the machine before use and check for any damage and defects. Please contact your supplier if there is any damage to the machine. Please keep all packaging out of reach of children. Place the machine in a horizontal position. Place the machine somewhere where it can be supervised by trained personnel.
Instruction for use Nova Instant COFFEE TECHNOLOGIES • • Open the upper lid and fill the container inside the machine Remove the container from the machine and fill. 3.2.1 Filling the container inside the machine 1. Open the door of the machine. 2. Open the lid on the container that needs refilling. Refill the container with the correct ingredients. 3. Close the upper lid. 4. If the container was completely empty, the supply will need refilling. • Hold the container above the waste bucket.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 3.3 Digital photo frame ➭ Please refer to the manuals enclosed for the correct use of the remote control and the digital photo frame. The USB connection can be seen on the inside of the door on the door plate when the door is opened. Operating the photo frame ☞ The photo display is operated with the remote control. The photos can be stored on a memory card (SD, MS, MMC, XD). The photos must be in JPG format.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4 MAINTENANCE AND CLEANING Accurate maintenance and in particular careful cleaning are basic conditions for good product quality and smooth operation. This machine has been developed to enable the owner or licensee to thoroughly clean and maintain it in a relatively short time and at low cost. ☞ 4.1 • • • • Safety instructions - maintenance and cleaning See also par. 3.1. Carry out the procedures taking into account the hygiene regulations.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.3 Service panel The service panel can be seen when the door is opened. From the service panel you can carry out the following maintenance tasks (if available): Button Function 1 Rinse brewing group 2 Rinse mixer 1 3 Rinse mixer 2 4 Rinse mixer 3 5 Open/close brewing group 6 Free/paid drink 7 Reset container counters 8 Read counters 9 Reset waste counter 0 Cleaning valves 4.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.5.1 Checking the ingredient containers 1. Open the door. 2. Check whether the ingredient containers still contain sufficient ingredients. 3. If necessary refill the containers as described in Chapter 3 4. Close the door. 4.5.2 Cleaning drip tray The drip tray must not be washed in a dishwasher. 1. Take the drip tray out of the machine carefully. 2. Empty the drip tray and clean it using water. 3. Put the drip tray back in the machine.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.5.4 Cleaning valves h 1. 2. 3. 4. 5. 6. 7. 8. The drink dispensed by the machine is very hot and may cause burns. Open the door and insert the service key. Place a cup of at least 1.5 L under the dispensing holder. Press button 0 on the service panel; clean valves. All valves are cleaned. Remove the cup. Turn the service key a quarter turn and remove it. Close the machine door. Empty the cup. 4.5.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.6 Weekly maintenance Carry out the following operations on a weekly basis: • Clean the mixer components 4.6.1 Cleaning mixer components Clean the following components during weekly maintenance: • Extractors • Mixing bowls • Hoses • Extraction lid Wash your hands before continuing with this procedure. 1. Open the door. 2. Remove the closed ingredient containers from the machine. Keep them in a clean and dry place. 3.
Instruction for use Nova Instant COFFEE TECHNOLOGIES ☞ The mixing chamber must latch securely in place to prevent leaks. Ensure that the green catch snaps back into place. 14.Insert the service key and turn it a quarter turn. 15.Place a 1.5 L cup under the dispensing nozzle. 16.Press button 0 on the service panel; cleaning valves. 17.Check the system for leaks. 18.Turn the service key a quarter turn and remove it. 19.Close the machine door. Figure 4-5 23 © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 4.7 Maintenance overview The labels with an overview of the maintenance to be carried out have been stuck to the inside of the door. 1 Day DAILY CLEANING 2 1 3 0 2x 1.5 L 5 4 1 Week WEEKLY CLEANING 1 4 0 2 3 5 6 1.5 L 000868623000 Figure 4-6 24 © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 5 RESOLVING PROBLEMS 5.1 LCD display on the selection panel If faults occur in the machine, the LCD display on the selection panel will display a fault message. 5.1.1 Fault messages Despite taking all precautionary measures, faults may occur in the machine. In this case, a fault message is displayed. The table below shows a number of faults that could occur and their causes and remedies.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 5.1.2 Selection panel in programming mode esc enter Figure 5-1 When the programming mode is used, the selection panel has the following functions: • + or -, these buttons are used to navigate the menu, or to increase or decrease values. • START, this button confirms the value that is set. • #, (on the service panel) this button is used to navigate back through the menu. 5.1.3 User menu (Operator) Press # on the service panel and enter the PIN code.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 5.1.4 Diagram of user menu MAIN MENU DRINK COUNTERS DRINK COUNTERS DRINK 1 - 10 ADDIT ADDIT 1 - 2 RESET ALL EXIT TIME & DATE CHANGE TIME HOURS-MINUTES-SECONDS CHANGE DATE DAY-MONTH-YEAR CHANGE DAY MONDAY - SUNDAY SHOW TIME ON/OFF CLOCK CORRECTION/24H 0 - 10 SEC. EXIT TEMPERATURE TEMPERATUUR A OPERATING DISABLED POWER SAVE ERROR SET PROBE VERSION LONG/SHORT PROBE EXIT EXIT Figure 5-3 27 © ETNA Coffee Technologies b.v.
Instruction for use Nova Instant COFFEE TECHNOLOGIES 6 TECHNICAL SPECIFICATIONS 6.1 Electrical system ☞ Refer to the machine type place for the correct configuration of your machine, see Chapter 1: Machine Identification. Description Value Main voltage 230 V Frequency 50 Hz Capacity 2.31 kW Fuse 16 A 6.2 Water system Description Value Water connection G 3/4" - outer ring Minimum water pressure 1.5 bar (150 kPa) Maximum permitted water pressure 8 bar (800 kPa) 1 1.
Instruction for use Nova Instant COFFEE TECHNOLOGIES Ambient conditions Description Value Ambient temperature 5 - 40 °C 6.5 Never place the machine in a room in which the temperature may drop below 0 °C. This is to keep the water in the machine from freezing. Dimensions and weight 372 604 90 6.4 150 759 124 Figure 6-1 Description Value Height 759 mm Width 372 mm Depth 604 mm Weight when empty 38 kg Weight when full 42.5 kg 29 © ETNA Coffee Technologies b.v.
