Installation manual

630167_3_Manual_Service_ST900_US_R‐emotion

12.0 Re‐assemble

 Oncetheserviceworkiscomplete,thefireshouldbere‐asse mbledbyreversingthe
 actionsdoneinprevioussteps,replacingthePilotCover,Burner,Fuelbedmedia,
 Glassassembly,andControlTray(ifremoved).
13.0 Re‐establishPowerandGasConnections

Withallap plicable
serviceworkcompletedandthefirefullyassembledagainthegas
canbere‐establishedandthebatteriesreplaced.

Checkgasinletpressureagainstdataplateatpressuretestpointusingamanome ter.
Adjustgaspressuretospecifications.

 Removethemanometerandreplacethetestpointscrew.

 Leak
testalltestpointsandgassystem joins/unions.

 Checkthatthepilotflamecorrectlyimpingesontheflamefailuredevice 
(thermocouplesshouldnotglowred,asthisindicatesthatthepilotflameissettoo
highandwillreducethelifeofthethermocouple).

14.0 Re‐fittheFascia

 TheST900 fasciausesthesefourhooksforattachingtothefire.Dothisbyliningup
 thefascia hookswiththereceptaclesonthesidesofthefire.Liftthefasciasothat
 thehooksareabovethereceptacles,andletitdropdownintopositionuntilit
is
 secureandfreefrommovement.















