Honeywell International Inc. 400 Maple Grove Road Ottawa, Ontario K2V 1B8 Canada CAGE: 38473 Telephone: 800-601-3099 (Toll Free U.S.A./Canada) Telephone: 602-365-3099 (International Direct) Website: https://aerospace.honeywell.com System Description, Installation, and Maintenance Manual Small SATCOM Part Number Model 90410350 Small SATCOM Kit Legal Notice Export Control These items are controlled by the U.S.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Proprietary Information Honeywell - Confidential COPYRIGHT BY HONEYWELL INTERNATIONAL INC. (“HONEYWELL”). ALL RIGHTS RESERVED. THIS DOCUMENT AND ALL INFORMATION CONTAINED HEREIN ARE THE CONFIDENTIAL AND PROPRIETARY INFORMATION OF HONEYWELL AND CONTAIN HONEYWELL TRADE SECRETS.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM export regulations. You will adhere to all U.S. export regulations as published and released from time to time by the U.S. Government.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM PROPERTY RIGHTS OF THIRD PARTIES, EVEN IF HONEYWELL HAS BEEN ADVISED OF ANY SUCH INFRINGEMENT. IN NO EVENT WILL HONEYWELL BE LIABLE FOR ANY INCIDENTAL DAMAGES, CONSEQUENTIAL DAMAGES, SPECIAL DAMAGES, INDIRECT DAMAGES, LOSS OF PROFITS, LOSS OF REVENUES, OR LOSS OF USE, EVEN IF INFORMED OF THE POSSIBILITY OF SUCH DAMAGES.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Copyright - Notice Copyright 2020, 2021 Honeywell International Inc. All rights reserved. Honeywell is a registered trademark of Honeywell International Inc. All other marks are owned by their respective companies. THIS IS THE CMM FOSI - DATE: 20171123 Page T-5 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page T-6 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TRANSMITTAL INFORMATION REVISION NUMBER 2 DATED 18 FEB 2021 TO HOLDERS OF SMALL SATCOM SDIM, PUB NO. D202006001015 AND IS ISSUED FOR USE IN SUPPORT OF THE FOLLOWING: Table TI-1 shows the applicable components. Table TI-1.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table of Highlights (Cont) Task/Page Description of Change Effectivity Page11 Paragraph 1.A.6 Updated procedural step. All Page11 Paragraph 2.A.5 Updated procedural step. All Page12 Paragraph 2.A.7 Added procedural step. All Page12 Paragraph 2.A.8 Added procedural step. All Page12 Paragraph 2.A.11 Updated procedural step. All Page12 Paragraph 2.A.12 Updated procedural step and added list items.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page TI-3 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM RECORD OF TEMPORARY REVISIONS Instructions on each page of a temporary revision tell you where to put the pages in your manual. Remove the temporary revision pages only when discard instructions are given. For each temporary revision, put the applicable data in the record columns on this page. Definition of Status column: A TR may be active, incorporated, or deleted. “Active” is entered by the holder of the manual.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page RTR-2 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SERVICE BULLETIN LIST Service Bulletin / Revision Number Title Modification Date Put in Manual Page SBL-1 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page SBL-2 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM LIST OF EFFECTIVE PAGES Subheading and Page Title T-1 T-2 T-3 T-4 T-5 T-6 Transmittal Information TI-1 TI-2 TI-3 Record of Temporary Revisions RTR-1 RTR-2 Service Bulletin List SBL-1 SBL-2 List of Effective Pages LEP-1 LEP-2 Table of Contents TC-1 TC-2 TC-3 TC-4 TC-5 TC-6 Introduction INTRO-1 INTRO-2 INTRO-3 INTRO-4 INTRO-5 INTRO-6 System Description 1 2 3 4 Date 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM LIST OF EFFECTIVE PAGES (Cont) Subheading and Page Date Subheading and Page Date Appendix A 44 45 Appendix B 46 47 48 49 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021 18 Feb 2021 * indicates pages changed or added data F indicates a right foldout LF indicates a left foldout Page LEP-2 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS LIST OF SECTIONS Title Page INTRODUCTION 1. 2. 3. How to Use This Manual ............................................................................................ INTRO-1 A. General ............................................................................................................... INTRO-1 B. Observance of Manual Instructions ....................................................................
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS (Cont) LIST OF SECTIONS (Cont) Title Page A. 2. 3. 4. 5. Prior to Installation ................................................................................................ 11 Mechanical Installation ................................................................................................... 11 A. Antenna Mounting ......................................................................................
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS (Cont) LIST OF SECTIONS (Cont) Title Page A. 6. 7. General ............................................................................................................... 37 LED Indicator .............................................................................................................. 37 A. Indications are as listed below: .........................................................................
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS (Cont) LIST OF SECTIONS (Cont) Title Page B. Configure the router ............................................................................................ 48 Page TC-4 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS (Cont) LIST OF FIGURES Figure Description Page 1 Indoor Unit Assembly ............................................................................................. 2 2 Forward and Return to UAV ................................................................................. 7 3 Effect of Banking on Data Rate .............................................................................
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM TABLE OF CONTENTS (Cont) LIST OF TABLES Table Description Page INTRO-1 List of Acronyms and Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Small SATCOM Kit Part Numbers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 2 Indoor Unit Component Specification . . . . . . . . . . . . . . . . . . . .
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM INTRODUCTION 1. How to Use This Manual A. General (1) This manual provides information about the installation of the Small SATCOM UAV System. (2) Standard maintenance procedures that technicians must know are not given in this manual.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM – SECTION 1 - SYSTEM DESCRIPTION – SECTION 2 - INSTALLATION – SECTION 3 - SYSTEM OPERATION – SECTION 4 - MAINTENANCE PRACTICES – SECTION 5 - TROUBLESHOOTING – APPENDIX A – APPENDIX B 2. Customer Support A. Honeywell Aerospace Online Technical Publications Website (1) Go to the Honeywell Online Technical Publications Website at (https:/ /aerospace.honeywell.com). – To download or see publications online. – To order a publication.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM C. References (1) Honeywell/Vendor Publications (a) Related Honeywell publications in this manual are shown in the list that follows: – Not applicable. (b) Other Publications: – The United States GPO Style Manual (available at http://www.gpo.gov/fdsys/ pkg/GPO-STYLEMANUAL-2008/content-detail.html) – IEEE Std 260.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table INTRO-1.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table INTRO-1. List of Acronyms and Abbreviations (Cont) TERM FULL TERM IPC Illustrated Parts Catalog LED Light Emitting Diode LGA Low Gain Antenna MCU Micro Controller Unit mm Millimeter MOPS Minimum Operational Performance Standards MPS Minimum Performance Standards NA Not Applicable NGSS Next Generation Satellite Services OPS Operational Program Software PN Part Number Pub.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page INTRO-6 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SECTION 1 – SYSTEM DESCRIPTION 1. General Information A. General (1) The Small SATCOM system is a very small and lightweight SATCOM terminal for use in UAVs for command, control and the streaming back of live video and other mission data. Refer to Figure 1. (2) The Small SATCOM is an Inmarsat SwiftBroadband single channel low gain system providing an internet data connect with rates up to 200 kbps.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 1. (Sheet 1 of 1) Indoor Unit Assembly Page 2 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM B. Hardware Part Numbers (1) At the time of writing of this document, the SATCOM Products were identified by the hardware part numbers indicated in Table 1. Table 1.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 2. Indoor Unit Component Specifications 3. COMPONENT CHARACTERISTIC SPECIFICATION Indoor Unit Part Number 90600511 Length 5.5 in. (140 mm) maximum Width 2.95 in. (75 mm) maximum Height 2 in. (50.8 mm) maximum Mounting Information Mounted inside the fuselage Weight 1.1 Lbs (0.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 3. Antenna Component Specifications 4. COMPONENT CHARACTERISTIC SPECIFICATION Antenna Part Number 89000015-009 Length 5.6 in. (142.24 mm) maximum Width 4.4 in. (111.76 mm) maximum Height 2 in. (50.8 mm) maximum Weight 1.06 Lbs (0.482 Kg) maximum Cooling Passive Cooling Maintenance No scheduled maintenance required EIRP 11.4 dBW nominal TX Operating Frequency 1626.5-1660.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM – Aircraft Earth Stations (AESs). – Space segment formed by three Inmarsat-4 and an Inmarsat-4A geostationary satellites that provides global coverage, except for the polar regions. This will be supplemented by Inmarsat-6 satellites, which are scheduled for launch in 2020. – A terrestrial ground infrastructure formed by the Satellite Access Stations (SASs). – Terrestrial interconnect networks.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 2. (Sheet 1 of 1) Forward and Return to UAV Page 7 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM (3) The following charts provide an indication of how maximum data rates can be affected by banking towards the satellite (positive) or away from the satellite (negative), depending on satellite elevation, when T4.5 bearers are being used. Satellite elevation can be obtained via the webUI or by using a satellite pointer app. Refer to Figure 3 for effect of banking on data rate and Figure 4 for elevation.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 3. (Sheet 1 of 1) Effect of Banking on Data Rate Page 9 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 4. (Sheet 1 of 1) BGAN Coverage Map Page 10 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SECTION 2 – INSTALLATION 1. General A. 2. Prior to Installation (1) Upon receipt of the terminal, the components should be confirmed present against the enclosed parts list and inspected for any damage. (2) The UAV satcom system’s environmental parameters should be reviewed to ensure that the intended usage is within its envelope.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM (7) The antenna mounting should be capable of dissipating at least 60W of heat from the antenna when in use. – The heat load is primarily through the bottom metal surface of the antenna. – Ensure that the mounting either conducts the heat away from the antenna or that there is sufficient airflow over the bottom of the antenna to take the heat out. (8) The antenna should be mounted on, and electrically bonded to, a ground plane.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM – The antenna mounting screws should be torqued to 2.37 to 2.60 N.m (21.0 to 23.0 in-lbs). – If sealing of the antenna holes is needed, then RTV is recommended to be applied around the edge of each hole between both the UAV skin and ground plane and the ground plane and antenna. Ensure that the antenna remains in electrical contact with the ground plane. Page 13 18 Feb 2021 © Honeywell International Inc.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 5. (Sheet 1 of 1) Antenna Dimensions Pages 14/15 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM B. Indoor Unit Mounting (1) The indoor unit should be mounted in the avionics bay of the UAV. (2) The indoor unit may be mounted in any orientation – The label is on the back, exterior face of the Indoor Unit. (3) The indoor unit’s environment should be maintained within its environmental parameters. – Anti-vibration mounts (not supplied) can be used to reduce the severity of the vibration.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page 17 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 6. (Sheet 1 of 1) Indoor Unit Dimensions Pages 18/19 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM C. Cable Routing (1) The installer should connect the Indoor Unit and Antenna with supplied RF cable. – The RF cable has a fixed loss requirement and should not be substituted or shortened, or the terminal will not function properly. (2) The RF connector torque settings depend on the connector and the recommendations are given in Table 5.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 7. (Sheet 1 of 1) Safety Information Warning and Caution Page 21 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM E. Engineering Drawings (1) For Terminal Outline and Installation, refer to Figure 8. Page 22 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 8. (Sheet 1 of 1) Terminal Outline and Installation Page 23 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM 3. Electrical Installation A. B. General (1) If there is a common UAV ground, the Indoor Unit should be electrically cross bonded with less than or equal to 3.0 milliohms direct current (DC) resistance. (2) Only 2 cables are required for operation. One to connect the boxes and the other to connect to the UAV. Indoor Unit Installation (1) General – The terminal does not require any calibration by the user/installer. 4.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 6. Termination Table From Connector FIND NO. REF DES To Connector PIN SIGNAL SIGNAL TYPE WIRE TYPE 1 2 V_IN POWER 6 1 P1 SDU 7 3 RX_N 8 RX_P 4 TX_N 5 TX_P WIRE FIND GROUP NO. 1 2 STP AWG 22 GND WIRE FIND NO.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 9. (Sheet 1 of 1) LEMO Termination Page 26 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM 5. Final Validation A. Installation validation should be by the following steps (1) Check that the LED lights up green. (2) If the SIM card supplied with the terminal is being used, then activate the airtime. (3) When the terminal is powered up and the antenna is not connected or if there is a fault, the status LED is red. (4) Observe safety distances to the antenna detail above throughout.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SECTION 3 - SYSTEM OPERATION 1. General A. 2. System Overview (1) The Small SATCOM UAV system is part of the Aircraft Earth Station (AES) that facilitates airborne satellite communications using Swift Broadband (SBB) services over the Inmarsat L-Band satellite communications network. (2) Set your laptop to obtain an IP address automatically or set a static IP address in the 192.168.1.2-255 or using satcom.honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 10. (Sheet 1 of 5) WebUI Configuration and Status Information Page 29 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 10. (Sheet 2 of 5) WebUI Configuration and Status Information Page 30 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 10. (Sheet 3 of 5) WebUI Configuration and Status Information Page 31 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 10. (Sheet 4 of 5) WebUI Configuration and Status Information Page 32 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 10. (Sheet 5 of 5) WebUI Configuration and Status Information Page 33 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM (3) It enables the setting up of a single background data connection, which is the most common use case. (4) It enables the setting up of 8 kbps, 16 kbps and 32 kbps streaming connections. (5) HTTP runs over Transport Layer Security (TLS), i.e., HTTPS, providing communication security over the Internet. The usage of TLS requires that the client must support an X.509 certificate to communicate with the terminal web server.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM – Reboot – Config (5) 3. See the ICD for more details about this interface, which is available for download from the terminal's web page. Example Use Case (VPN) A. General (1) A common use of Satcom is to allow equipment based on the ground to interrogate equipment on the UAV, for example to pull position data from the flight controller, refer to Figure 11.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Figure 11. (Sheet 1 of 1) Example Use Case (VPN) Page 36 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM 4. INMARSAT Operational A. General (1) Class 15 Services. • Standard IP • Streaming IP • BGAN IP Voice • Combinations of the above. (2) Background, streaming and subscription traffic classes are supported. (3) User is able to set up 1 primary and up to 9 PDP contexts on a connection. • Primary and secondary connections can be set up via the RESTful interface • The WebUI can only set up a primary connection 5. USIM A. 6.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 7. Ground Level Thermal Capabilities Mounting Mounting Description Minimum Air Flow Required to Operate at 55°C (131°F) Standard Indoor Unit is mounted or bolted directly to insulating surface. For instance, onto a composite surface. 123 CFM On Controlled Plate Indoor Unit is mounted or bolted directly to a thermally conductive surface. For instance, actively controlled cooling plate.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SECTION 4 – MAINTENANCE PRACTICES 1. Maintenance A. General (1) B. C. D. The Indoor Unit should be isolated from the UAV power network prior to any maintenance to avoid any possibility of personnel being irradiated. Cleaning (1) The Indoor Unit and antenna can both be cleaned with a microfibre or soft cotton cloth dampened with clean water. (2) Chemical cleaning agents should not be used.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Blank Page Page 40 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM SECTION 5 - TROUBLESHOOTING 1. Installation Issues A. General (1) 2. Most common installation issues include breaks/disconnection in the antenna cable and power supply. Operation Issues A. General (1) The fault possible causes and its troubleshooting solutions are listed in below Table 8. Table 8.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 8.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM Table 8.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM APPENDIX A - CERTIFICATION AND REFERENCE DOCUMENTS 1. General A. B. 2. Reference Documents (1) SP-90600571 - Small Satcom External ICD. (2) SP-90600570 - Small Satcom System Requirements Document. Regulatory (1) 47 CFR, US FCC Title 47 CFR: Part 87 for Aeronautical classes (section §87.139 Emissions Limitations). (2) European Regulation (EC) No.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM (8) NOTICE: Changes or modifications made to this equipment not expressly approved by EMS Technologies Canada, Ltd., a wholly owned subsidiary of Honeywell International Inc. may void the FCC authorization to operate this equipment. (9) NOTICE: This device complies with Part 15 of the FCC Rules [and with Industry Canada licence-exempt RSS standard(s)].
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM APPENDIX B - EXAMPLE USE CASE (VPN) SETUP DETAILS 1. VPN Server (Ground Side) A. Install OpenWRT on the router (1) Download OpenWRT 19.07.4 from the below link: http://downloads.openwrt.org/releases /19.07.4/targets/ar71xx/generic/openwrt-19.07.4-ar71xx-generic-gl-ar750s-squashfssysupgrade.bin (2) Perform upgrade – Connect your computer to any of the LAN ports on the router. – Set the IP address of the computer to 192.168.1.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM # cp /etc/easy-rsa/pki/ca.crt /etc/openvpn/ # cp /etc/easy-rsa/pki/dh.pem /etc/openvpn/ # cp /etc/easy-rsa/pki/issued/server.crt /etc/openvpn/ # cp /etc/easy-rsa/pki/private/server.key /etc/openvpn/ (11) Copy the following files to your machine: (These will be required by the client) /etc/easy-rsa/pki/ca.crt /etc/easy-rsa/pki/issued/smallsatcom.crt /etc/easy-rsa/pki/private/smallsatcom.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM 2. VPN Client (Air Side) A. Install OpenWRT on the router Follow the same directions as for the server to install OpenWRT. B. Configure the router (1) Set the router LAN IP to 192.168.1.2. Disable the DHCP server. (2) Delete WAN6 interface from Network -> Interfaces. (3) Temporarily connect the router to the internet (via WAN port or use a mobile hotspot on the mobile phone) and open an SSH session.
SYSTEM DESCRIPTION, INSTALLATION, AND MAINTENANCE MANUAL SMALL SATCOM (13) Connect the router to the Small Satcom IDU using the WAN port. The router should establish connection to the internet and open a VPN tunnel to the server automatically. Page 49 18 Feb 2021 © Honeywell International Inc. Do not copy without express permission of Honeywell.
