Pump Manual
2
Breathable Air Warning
This compressor/pump is NOT equipped and should NOT be used “as is” to supply breathing quality air. Intake air can
cause carbon monoxide or other contaminants. For any application of air for human consumption, you must fit the air
compressor/pump with suitable in-line safety and alarm equipment. This additional equipment is necessary to properly
filter and purify the air to meet minimal specifications for Grade D breathing as described in Compressed Gas
Association Commodity Specification G 7.1 – 1966, OSHA 29 CFR 1910. 134, and/or Canadian Standards Associations
(CSA).
DISCLAIMER OF WARRANTIES
In the event the compressor is used for the purpose of breathing air application and proper in-line safety and alarm
equipment is not simultaneously used, existing warranties are void, Airbase Industries disclaims any liability whatsoever
for any loss, personal injury or damage.
DANGER!
▪ READ INSTRUCTION MANUAL BEFORE
OPERATING
▪ RISK OF FIRE OR EXPLOSION – Do not
spray combustible/flammable liquid in a
confined area. Spray area must be well
ventilated. Do not smoke while spraying or spray
where sparks or flame is present. Arching parts –
keep compressor at least 20 feet away form
spraying area and all explosive vapors.
▪ RISK OF INJURY – Moving parts can cause
serious injury. Do not operate with guards
removed. Machine may start automatically.
Disconnect power before servicing.
▪ RISK OF BURSTING – Bypassing, modifying
or removing safety/relief valves can cause
serious injury or death. Do NOT bypass, modify
or remove safety/relief valves. Do NOT direct
stream at body. Rusted tanks can cause explosion
and severe injury or death. Drain tank daily or
after each use. Use only suitable air handling
parts acceptable for pressure of not less than the
maximum allowable working pressure of the
machine.
▪ RISK OF ELECTRICAL SHOCK –
HAZARDOUS VOLTAGE: Can cause serious
injury or death. Disconnect power and bleed
pressure from the tank before servicing.
Lockout/Tagout machine. Compressor must be
connected to properly grounded circuit. Do not
operate compressor in wet conditions. Store
indoors.
▪ HOT SURFACE. Can cause serious injury. Do
not operate with guards removed. Disconnect
power before servicing. Lockout/Tagout machine
IF CONNECTED TO A CIRCUIT PROTECTED
BY FUSES, USE TIME-DELAY FUSE MARKED
“D”
COMPLIES WITH CCR462 (L)(2).
DO NOT USE BELOW GARAGE FLOOR
OR GRADE LEVEL