Service manual

5
Electrical Operation (Gas Dryers Models) 50
Electronic Control Board Circuits 50
Drive Motor Circuit 51
Temperature Sensing Circuit 51
The Heating Circuit 51
Drying Time 52
SECTION F - TROUBLESHOOTING 53
Reading Error Codes 53
Failure Code Chart 53
Troubleshooting Flow Charts Index 55
Electric Dryer Completely Inoperative 56
Gas Dryer Completely Inoperative 57
Electric And Gas Dryers; Blower Motor Runs But Drum Does Not Turn 58
Electric And Gas Dryers; Longer Than Normal Drying Times 56
Electric Dryer Not Heating Properly 59
Gas Dryer Not Heating Properly 60
Electric and Gas Dryers; Dryer Over Heating 60
Electric Dryers; Blower Motor Runs But Dryer Does Not Heat 61
Gas Dryers; Blower Motor Runs But Dryer Does Not Heat 62
Electric And Gas Dryers; Clothes Not Dry In Auto Cycle 63
Electric And Gas Dryers; Selector LEDs Do Not Light. 64
SECTION G - TEARDOWN 65
Removing The Top Panel 65
Removing The Console 65
Removing The Control Board 66
Removing The Control Board’s Rear Cover 66
Removing The Interface Board 66
Removing The Selector Knob 66
Removing The Button Spring 67
Removing The Buttons 67
Removing The Loading Door 67
Disassembling The Loading Door 68
Removing The Catch Plate 69
Removing The Catch 69
Removing The Door Switch 70
Removing The Front Panel 70
Replacing The Sensor Bars 71
Replacing The Front Panel Air Duct 71
Replacing The Drum Light Bulb 72
Replacing The Drum Light Housing 72
Replacing The Drum Light Socket 72
Replacing The Felt Seal 72
Replacing The Foam Seal 72
Removing The Rear Access Panel 73
Releasing The Dryer Belt 73
Removing The Vane From The Drum 73
Removing The Drum 73
Removing The Belt 74
Removing The Hitch Ball From The Drum 74
Removing The Teflon Glides 74
Removing The Drum Heat Shield (Electric Dryers) 74
Removing The Hitch 75
Removing The High Limit Thermostat 75
Removing The Thermal Limiter (Electric Dryers) 75
Removing The Heating Element Assembly (Electric Dryers) 75