Installation Guide
Elastilon Product Manual
~ 11 ~
What are examples of flooring not recommended for use with Elastilon?
It is not recommended to use Elastilon with odd lots, cabin grade, and rustic grades of hardwood flooring.
If unsure please contact ElastilonUSA directly at 1-877-526-9663.
How does Elastilon work with thinner boards?
Although the instructions are common to the installation of Elastilon with all hardwood floors, particular
attention must be given to the following when installing thinner boards. ie, ½”(12.5mm), 3/8”(10mm)
and 5/16”(8mm)
All end joints must be glued throughout the installation.
The sub-floor must be flat to within .08 inch over 8 ft (2mm over 2.5m)
Expansion room must be maintained around all walls and obstacles.
Transition moldings need be placed at all doorways and hall entrances and areas greater than 30ft
in width or length.
Extremely heavy furniture can cause noticeable deflection with thinner boards. Try to distribute
weight over a greater area.
Each board should be carefully inspected prior to the installation. Boards should be straight and
flat without bowing, warping or cupping prior to installation.
Proper acclimation of the wood floor prior to the installation
Maintaining the proper room conditions prior, during and after the installation.
Is floor noise common?
Deflection may cause a minimal amount of friction or "floor noise". Note that normal floor noise will vary
from one installation type to the next depending on sub-floor type, sub-floor deflection, species, milling
and type of flooring material, relative humidity and the amount of topside pressure applied to the flooring
material. For these reasons, "Floor Noise" is not considered a defect.
Can I join the Elastilon rolls with tape to seal all the edges?
The Elastilon rolls should never be attached or joined together on the long length of the rolls. This will hamper
the elastic nature of the product and could cause floor failure. It is recommended that the rolls of Elastilon be
loose fitted side by side. It is allowable to join the short ends (3 ft side) of the rolls with tape.
What is the Shelf life of Elastilon?
Shelf life of the product is at least 2 years when stored as stated on the technical data sheets: @ 21°C,
50% relative humidity, no direct sunlight/ strong artificial light.